Atkore - Earnings Call - Q3 2020
August 4, 2020
Transcript
Speaker 0
Greetings and welcome to the Atkore International Third Quarter Earnings Conference Call. At this time, all participants are in a listen only mode. After the speakers' presentation, there will be a question and answer session. As a reminder, this conference is being recorded. I would now like to turn the conference over to your host, John Deitzer, Vice President of Investor Relations.
Thank you. You may begin.
Speaker 1
Thank you and good morning everyone. I'm joined today by Bill Waltz, President and CEO as well as David Johnson, Chief Financial Officer. We will take your questions after comments by Bill and David. I would like to remind everyone that during this call, we may make projections or forward looking statements regarding future events or financial performance of the company. Such statements involve risks and uncertainties such that actual results may differ materially.
Please refer to our SEC filings in today's press release, which identify important factors that could cause actual results to differ materially from those contained in our projections or forward looking statements. In addition, any reference in our discussion today to EBITDA means adjusted EBITDA. With that, I'll turn it over to Bill.
Speaker 2
Thanks, John and good morning everyone. I'm pleased to report that Atkore delivered solid results in the third quarter despite the challenges associated with COVID-nineteen pandemic. I believe our strong operational focus and culture of safety helps us as we navigate through these uncertain times. As we start on Page three, in the third quarter we delivered an adjusted EBITDA of $64,000,000 as our margins performed better than our expectations given the strong cost control measures we implemented throughout the organization. It is through the actions of so many of our employees that we were able to increase our cash balance by 100,000,000 and end the quarter with a balance of $237,000,000 I'm pleased to announce that shortly after the quarter ended, we were able to come to agreement with the United Steel Workers Union to ratify a new agreement for our Harvey, Illinois location.
At Atkore, we are focused on building a long term sustainable business and this agreement certainly helps. Given the continued uncertainty and market volatility, we estimate our FY twenty twenty net sales, EBITDA and adjusted EPS to be down approximately 10% versus prior year. Now let me take a moment to summarize my key takeaways regarding the quarter and recent events and then David will go into the results in more detail. First, the team delivered solid results in Q3 driven by our disciplined use of the Atkore business system. Second, we are in a strong financial position with two thirty seven million dollars in cash at the end of the third quarter.
Third, as much as we focused on managing through these current conditions, we remain committed to building an even stronger Atkore for the future. With that, I'll turn the call over to David who will walk us through the quarter in more detail.
Speaker 3
Thank you, Bill, and good morning, everyone. As Bill mentioned, we are pleased with the results in the third quarter. Moving to our consolidated results on Slide four. Net sales declined 22% primarily due to the unfavorable market conditions caused by the pandemic. Adjusted EBITDA was $64,000,000 and our adjusted EBITDA margin was approximately 17% in the quarter.
Our adjusted EPS was $0.67 as lower interest expense helped partially offset the lower earnings. Turning to Slide five. Net sales declined $109,000,000 due to lower volumes and lower selling prices. The lower selling prices are a result from declines in key raw material inputs such as steel and resin. Through outstanding operational and commercial execution, our team was able to partially mitigate the impact on profitability from the decline in the sales volume.
Moving to the adjusted EBITDA bridge, the previously mentioned volume declines had the largest impact in the quarter with an unfavorable impact of $35,000,000 However, by following the Atkore business system and controlling costs, our team was able to drive $10,000,000 in year over year productivity benefit. Despite a significant market reduction, our commercial team did an excellent job of communicating the value of ACCOR to our customers, as our lower selling prices were in line with the changes in our input costs. This resulted in a decremental adjusted EBITDA margin in the quarter of approximately 23%, which was better than our initial expectations. Moving to our Electrical Raceway results on Slide six. The segment had a solid quarter with an adjusted EBITDA margin of 20%.
Net sales declined 23% as we experienced lower volumes due to the pandemic. However, our focused product categories only declined in the low to mid teen percentages in the quarter. Turning to the Mechanical Products and Solutions segment on Page seven. Net sales only declined 18% as demand for large renewable energy projects and recreational equipment helped support the business during the quarter. Adjusted EBITDA margins declined to 12% and are down four eighty basis points versus a very strong prior year comparable.
Moving to Page eight, let me take a moment to review our debt structure and liquidity. We have $846,000,000 of total debt associated with our term loan facility. This loan does not mature until December 2023 and we have no scheduled principal payments prior to maturity. As Bill mentioned, we ended the quarter with $237,000,000 in cash or a net debt position of $6.00 $9,000,000 or 1.9 times trailing twelve month adjusted EBITDA. We are confident in our liquidity position and we have not drawn on our asset based loan.
Turning to Slide nine, I want to highlight that we are now down a full turn in our net debt to adjusted EBITDA ratio over the past eighteen months. As we discussed in our last call, we expected the third quarter to be solidly cash flow positive, and we're quite pleased with the $100,000,000 increase in our cash position. Even during these challenging conditions, the business has proven that it has a strong ability to convert earnings to cash. And now let me turn it back to Bill for our outlook.
Speaker 2
Thanks, David. Turning to Slide 10. With the solid performance that we saw in Q3, we now expect our full year net sales, adjusted EBITDA and adjusted EPS to be only down approximately 10% versus prior year. This is an improvement versus our 10% to 15% estimate in May. However, this estimate is based on our assumption for our net sales in Q4 to be down approximately 15% versus prior year and our decremental EBITDA margins to be in the range of 30% as we anticipate certain expenses to slowly return to the business and as we recognize other one time events in the quarter.
In addition, we believe this approximate run rate for decremental EBITDA margins will continue into fiscal year twenty twenty one as we will have two very strong quarters to compare against in the first half of next year. While we are proud of the cost controls that we've implemented in the face of this unprecedented situation, there will be expense headwinds next year as we make continued investments that will help us improve our capabilities and drive future growth. One additional item to highlight on Page 10 is that we are now increasing our estimate for FY 2020 capital expenditures up to $28,000,000 to $32,000,000 due to the strong cash flow generation. We want to continue to invest in projects that will deliver value for our customers and shareholders in the future. Speaking of the future, I would like to turn to Slide 11 to introduce our new logo and tagline.
This has been a project well over a year in the making and we wanted to share it with you today because we believe it's essential to who we are and at the core of what we do. Our new tagline of Building Better Together represents our belief that by working together with all of our stakeholders that the best is yet to come for Atkore. Operator, please now open the line for questions.
Speaker 0
Thank you. And our first question comes from the line of Andy Kaplowitz from Citigroup. Your line is open.
Speaker 4
Hey, good morning guys.
Speaker 2
Good morning, Andy. Good morning, Andy.
Speaker 4
Bill, so just thinking about the cadence as you went through the quarter, your sales were down about 20%. But could you give us more color on the monthly cadence, what you saw in July? Did you see any improvement in your sales volume? And if so, in what part of the business? I know you're guiding to 15% for Q4, which is what you did what you guided to for at last quarter for Q4.
So any improvements that you're seeing though in the business?
Speaker 2
Yes, Andy, great question. A very linear improvement month to month. So as I think we said at the last call where we were down a little less than 30%, you can probably figure May was about the average for the quarter that 22%, 23% and then June was approaching the 15% that we're now seeing going into Q4. And July was consistent with Yes. In July, yes.
So we're talking July was consistent with the direction we've given for Q4.
Speaker 4
Okay. And then just following up on that, Bill, you guided to 30% decrementals again for Q4, but as you said, you did 23%. And it's hard not to notice the $10,000,000 in productivity that you had in the quarter. I think you've guided about $15,000,000 a year on average usually. And I know you mentioned some temporary costs have to come back.
But I think the question from us is how much conservatism is baked into the guidance here and the potential to do better than 30% going forward?
Speaker 3
Hey, Andy. So this is David. I'll take that one. So first of all, on that $10,000,000 we estimate about half, a little bit more than half is kind of one time COVID related productivity improvements that we're seeing by just reducing costs. And you can imagine right now in the P and L, you have very low things like medical expenses and what have you.
So in Q4, the 30% decremental, there's a couple of things going on there. One, we do have some one time costs in the quarter. So as we announced, we concluded our Harvey Union contract, which with it came some one time costs. We also believe that some of the costs such as medical, what have you, as facilities start to open up, we will see some more of those expenses in the quarter. The third point is, especially for MP and S, as we had mentioned way back when we first did guidance, we did know that Q4 was going to be a tough comp to begin with.
And we were talking about price versus cost and our initial guide was somewhere around the negative $10,000,000 for the year. We're now probably slightly positive for the year, but Q4 is likely to be a little bit unfavorable, again mainly because of that very favorable comp from last year.
Speaker 4
Very helpful guys. And just one more follow-up from me. As you've had a few months to sort of watch the pandemic's impact on your business, Obviously, some fundamental changes. I think we talked last quarter about more focus on data centers and warehouses, maybe a little less focus going forward on office and retail. So how do you think about all that as you go into 2021?
Can your business trend better than ultimately what non residential starts are going to be?
Speaker 2
Yes, Andy, I think so. I'm going to answer two questions just down in front of one. As you look at different forecast next year for the market, it probably is going to be down in the low to mid single digits. We could get into depth with that for anyone. But I do think as we continue to add more value, new product development, you mentioned data centers, there's a huge focus from us on how we grow in that market faster than the market itself and put more effort there.
And just our co loads, all the value prop, we should be able to do better than the markets. I was going guide in November, but
Speaker 4
Appreciate it. Thanks.
Speaker 2
Thanks Andy.
Speaker 0
Our next question comes from the line of Deane Dray from RBC Capital. Your line is open.
Speaker 5
Thank you. Good morning everyone.
Speaker 2
Good morning Dean.
Speaker 3
Good morning Dean.
Speaker 5
Hey maybe we could just pick up where we left off with Andy's last question. Just to clarify when you say low to mid single digit is that for non res overall value in place? What can you just clarify that, please?
Speaker 2
Yeah. Dean, I think, and again, this is the most unprecedented time to try to do a forecast and we're not guiding for 2021 yet. But I would think most indicators for put in place next year would have 2021 down low to mid single digits. There's a great site. I'm getting very specific here, AII, a i..com that gives forecast everywhere from Dodge to Moody's to different other forecast organizations.
And they would have 2021 down around 4.8% to be overly precise with a lot of variance in there. And that's the same thing we're seeing, whether it's talking to distributors, contractors, ABI, with having record low numbers here for the last couple of months, there will be some headwind next fiscal year. But again, we're talking at least at this stage, the low single digits. And then to Andy's question, we hope to outperform that as we have in the past.
Speaker 3
And the one other thing that I mentioned, that is a kind of a calendar look and then of course for our fiscal year, it's going to be a little bit interesting for us when we give our outlook next quarter because we will be comping against two non COVID quarters. So for us, it's going to be a little bit more of a tale of two different halves for FY 2021.
Speaker 5
That's real helpful. And then qualitatively, the way some people are looking at the non res market is as states reopened any construction project that had been started got the green light to continue. And so the worry or the issue, the concern here is what the pipe what does the pipeline look like after these current projects are completed? Are we going to hit an air pocket? And this depends on kind of CEO confidence.
So but you've got your ear to the ground there. What are you seeing in terms of the pipeline, the funnel after these current projects are completed?
Speaker 2
Yes. I'll end with the answer then give you some more specific. I think that ties, Deane, to our earlier earlier answer that low single digits down for next year. To your point, I am not aware of any project of significance that somebody's dug into the ground that's been stopped. There has been projects without meeting any specific ones, but if you can imagine in Orlando, just as example, whether it's an airport or an entertainment complex, if that was on the books, but they haven't started the shovel, they have postponed in some cases.
ABI has been low and therefore go out nine months from now, you know, the starts will be a little bit slower. The only question I would have or push is where you say, hey. You know, is there a pocket? There's just jobs that are three months long to do. There's other things that take three years to schedule that I think the statistical averages, and I go back there for to go next year, put in place should be down low single digits.
There's not like a hiccup to say, oh, I'm really concerned about two months just, but we'll continue to do well. We've done well. I mean, back to plug it this year. Think of this, as much as we're down in this last quarter and we've had neutral basically spreads and a year ago, to David's point, we said the second half of this year was going to be tough because of the historically high spreads. We'll manage through new product development, continue to work on co loads and a lot of other customer focusing things, including digitization.
I'm an optimist, but I'm also setting the ground for it's not like all of a sudden a vaccination is going to come here at the end of the year there's going to be a V shaped recovery in non res, would be unrealistic for anybody to factor that in.
Speaker 5
All right. That's all real helpful. Let's switch gears here and talk about your distributors. And there had been thought last quarter that there was still some destocking to happen, you thought maybe an additional week. How did that actually play out?
Speaker 2
Yes. It played out the following things. I think inventory is back in line, the year. That the up. By the time we had our earnings call, they were destocking because manufacturers are up and job sites are down.
And then I think over the months of, like, May and June, maybe even July, people have noticed that we're in the new normal as much as this can be a new normal and they're back to their five to eight weeks of inventory and they're doing well and obviously we're going well. And being that obviously plays out a little
Speaker 3
bit differently by geographic location. So like the Boston area was really heavily impacted and now it's starting to come back. So there's different parts of the country where it wasn't as impacted and now it's opening up and so on and so forth. But overall, I think inventory is in line. Yes.
Speaker 5
Good to hear. Just last one from me on CapEx, the increase. You described just kind of generically that you're looking to create value. But can you be any more specific as to either a project or type of project? And then maybe David can share with us the internal rates of return ranges that you see, what kind of returns you're actually getting.
Speaker 2
I'm smiling Dean because with all these questions, they're good questions. We're pointing back and forth fighting for who gets the answer and I want on this one other than I'll pass it to him on the return on investment. It's across the board. Is we're optimistic. I'm not just talking for fiscal twenty twenty one, but literally for the next test decade.
We did events like a Shark Tank event, challenged our employees for new product development ideas, came up with 30 different submissions, funded seven. So you're starting to see a little bit of that. We're working on digitization efforts. So there's a little bit more funding for that. There's larger capital projects for some of our facilities.
There's some environmental things we're working on. So it's across the board where, in my mind, the organization complement all 3,600 to 4,000 employees who are driving that working capital and cash flow. The Gong guys, we know what we're dealing with as much as anybody does with COVID, and we're moving ahead. So we're making investments, including CapEx because there's lots of projects with real good returns for our shareholders, our customers and society. So that's the high level being, but there's not just one project.
And I'm excited to invest because I know they are going to
Speaker 3
be good returns for And these returns are we're between two and three year type of returns, Deane. And if you remember, when we first gave our outlook at the beginning of this year, we're probably in this capital range at the beginning of it. So we had reduced it last quarter, not really just being prudent regarding capital going into COVID, not really understanding exactly how the markets were going to go. Now we feel a little bit more comfortable. We generated $100,000,000 of cash increase.
We feel comfortable that we can go and release this investment in Q4.
Speaker 2
Yes. And Dean, if I can add to, I think with your very first question where you made some comment around or statement like, hey. With Andy on CEO confidence, next year, again, the markets from what everybody predicts is slightly down. But for Atkore and the leadership and employees, we're bullish on the future just like the last page I wrapped up on page 11. It's about how we rebrand Atkore, how we invest.
So, yeah, will there be some headwinds in the market? Yes. Do we have a phenomenal team that's focused on bringing value to our customers? Absolutely. And therefore, we're moving ahead in every facet of the company and our initiatives.
Speaker 5
Great. That's all helpful. And I really like the Shark Tank event concept. I'll talk more about that offline, but great job. Thank you.
Speaker 2
Sounds great. Thank you. Thank you.
Speaker 0
Our next question comes from the line of Deepa Raghavan from Wells Fargo. Your line is open.
Speaker 6
Hi, good morning everyone.
Speaker 2
Good morning Deepa. Good morning Deepa.
Speaker 6
Hello. My first question is on commodity deflation and the price pass throughs. Are you now tracking 100% price pass through given the commodity deflation or are you still slightly positive? Can you also talk about how we should think about commodity deflation versus price pass through in the next couple of quarters and entering 2021?
Speaker 2
Yes. David, do you want to answer?
Speaker 3
Yes. So Deepa, going back to our ACCOR bridges on Slide five, you can see that the impact on commodities on the sales line was $10,000,000 and on the EBITDA line was around $1,000,000 So I would say that we pass through or we are able to adjust accordingly our prices with our commodity costs. Some quarters will be plus one, minus one and year to date we're actually positive. And remember, we're year to date positive versus a couple of years of record increases year over year. So going into the year, we said that the full year would be a negative 10.
Now even with COVID, we will be favorable to that And Q4 will be a little bit unfavorable, but that's a lot more to do with the comparable of last year than it is any kind of sequential situation.
Speaker 6
Okay, got it. That's fair. Can you remind us, Bill, what the new construction versus renovation mix is in down cycles for Atkore specifically? And also can you talk about how Atkore is working to place itself favorably towards the renovation side of Trent near term?
Speaker 2
Okay. Deepa, you broke up a little bit. Renovation versus Renovation. I apologize. Thanks, David.
Renovation probably in that 15% to 20% of the market. Obviously, I think that will be a headwind or a tailwind for us. I said it wrong. Sorry. Purely from the standpoint of you think about office buildings, and I don't think people are going to be building as many office buildings, but the whole renovation, open workspaces and the offices, you know, structured walls and so forth.
So I think we will have some pickup. It's always just a little tougher for us selling through distributors to get precise numbers on how it is or how much it's growing, but that should be good. And then again, I just think the more we work with our products, our labor savings with contractors and pool products through our distributors and any of these growth initiatives, we will do better than the markets.
Speaker 3
And I think, Deepa, if you remember, we talked about investing in technical sales managers in the last, say, year time period. Those folks are a lot more on the ground kind of even ahead of the distributor when projects come up. So I think having those resources out there will certainly help us capture any of those opportunities, at least our share of those opportunities.
Speaker 6
Got it. Just switching gears to capital deployment. How are you thinking about M and A continuity in the current environment? And that's my final question. Thanks.
Speaker 2
Yes. So we are starting to look. I mean, we never really stopped, but we obviously paused. It's a little hard with the COVID there last couple of months even to fly to a couple of locations. But we're back moving ahead again.
So I think it still always be with the Atkore business system, the discipline we've talked about in the past. In other words, four key things. Is it strategic? Does it have synergies? Will we keep and continue responsible?
I'll make a plug again for the 1.9 leverage ratio. And do we have the management bandwidth? And the answer is that is absolutely. So with that said, there's give or take 100 acquisitions in the pipeline. There's ones we're working today.
We'll be prudent throughout the process. And we will spend or at least we will in our capital appointment, think of generically around 50, maybe a 100,000,000. You know, it depends if there's the right deal for next year as we continue to spend money on internal CapEx and shareholder buyback in the $15,000,000 and so forth.
Speaker 6
Okay. So your pipeline still continue to be full and you're looking, I guess that's the message. Nothing the score hasn't really pushed that some of the targets to the wider
Speaker 2
No, not really. No, I wouldn't say, you know, I've had questions including from employees both ways like, hey, is this a buying spree? I don't know if I'd say that. On the same hand, I don't think we pushed things off. We had for a couple months, but we're back in the process.
We have a regular routine monthly call. I met with one of our finance leaders yesterday just on the status of a couple of specific details. It's we have a drumbeat with the Atkore business system and we're continuing to execute it. I really, for all of our investors out there, the way I'm looking at it, there is the challenge of COVID. Other than that challenge, the Atkore business system, our employees, our initiatives really have not changed.
We are moving forward drumbeat by drumbeat on every facet of the organization from talent to investments internally to M and A to the new branding with extra focus on things that are going to be growing like data centers. So it's at core and will continue to be at core.
Speaker 6
Thank you very much. I'll pass it on.
Speaker 2
Great. Thanks, Deepa.
Speaker 0
Our next question comes from the line of John Walsh from Credit Suisse. Your line is open.
Speaker 7
Hi, good morning.
Speaker 2
Good morning, John.
Speaker 7
Hi. So a lot of questions already on the forward look of the market, tough to call. But one thing we've heard consistently is So there's going to be different verticals leading next year versus probably what we've seen last year or even before. Can you talk about how that change in leadership impacts your mix?
And if there's any big discernible changes in mix, if it's a hotel versus a warehouse versus an office for your products?
Speaker 2
Yes. The following answer is slightly positive to neutral. In other words, if you think about the things that you just mentioned, data centers, great for us. Health care, that should also be up, you know, going into next year, great for us. And just think of all the electrical things.
So the mix there, very positive. On the other hand, warehouses, you know, a lot of square footage, some electrics, but not as much. So overall, it's gonna be helpful. But I also, John, wouldn't model in a massive increase because of it. And then it's just up to our teams, which I'm very confident in, to how we get in our unfair share of those vertical markets and a lot of discussion, a lot of effort.
And that's again, data centers growing is not a new phenomenon. So we've been focused on it for a couple of years now. And I think as we go forward, you'll see more effort.
Speaker 7
Great. And then just a couple of questions so far around the cost avoidance. Is there a way to put these items as we think about next year into a structural bucket, a variable where you're potentially going to maintain very tight control on whether that's T and E, etcetera, and then kind of the stuff that's truly variable with volume such as like compensation for employees. Is there a way to use that construct to help us think about some of the moving parts as we think about next year?
Speaker 3
Yes. I think when we give our outlook for next year and next quarter, we'll definitely provide more color around those individual items. And you're right, there's going to be part that goes you know, that's gonna come back into the P and L like medical and what I view. There's others that are gonna be controllable by us such as T and E. And then there's our normal productivity which we don't wanna lose sight of the fact that we still have, productivity projects, investment in capital, whatever.
So when we give our outlook next quarter, we will monetize all those pluses and minuses year over year. As of right now, we felt that it was appropriate to at least give some guidance of what we were thinking about going into next year knowing that we were going get a lot of questions around what we see the market and what have you. And so that's why we've been talking about the round low mid single digits for the market next year.
Speaker 7
Great. Well, we'll look forward to that discussion next quarter. Appreciate the color. Thank you.
Speaker 2
Thanks, John. Thank you.
Speaker 0
And we have no further questions in queue today. I'll turn the call back to Bill Waltz for closing remarks.
Speaker 2
Great. Thank you. Before we conclude, let me summarize three key takeaways from today's discussion. First, the solid results we delivered in the third quarter are the result of our strong operational focus from our teams and the commitment to the Atkore business system. Second, we're in great financial position with a cash position of $237,000,000 And third, we're taking the necessary steps to keep our employees safe while managing through the current conditions and also truly growing the business we want for the future to make it even stronger.
With that, thank you for your support and interest in Atkore and we look forward to speaking with you during our next quarterly call. This concludes the call for today.
Speaker 0
Ladies and gentlemen, this concludes today's conference call. Thank you for participating. You may now disconnect.