O-I Glass - Earnings Call - Q1 2021

Transcript

Speaker 0

Good day. Thank you for standing by, and welcome to the OIGLASS First Quarter twenty twenty one Earnings Conference Call. At this time, all participants are in a listen only mode. Later, we will conduct a question and answer session and instructions will follow at that time. As a reminder, this conference is being recorded.

I would now like to hand the conference over to Chris Manuel. You may begin.

Speaker 1

Thank you, Blue, and welcome everyone to the O I Glass first quarter twenty twenty one earnings conference call. Our discussion today will be led by Andres Lopez, our CEO and John Hodrick, our CFO. Today, we will discuss key business developments and review our financial results. Following prepared remarks, we'll host a Q and A session. Presentation materials for this earnings call are available on the company's website at 0i.com.

Please review the Safe Harbor comments and disclosure of our use of non GAAP financial measures included in those materials. Now I'd like to turn the call over to Andres, who will start on Slide three.

Speaker 2

Good morning, everyone. We appreciate your interest in O I Glass. Overall, we are pleased with our performance during the first quarter as adjusted earnings of $0.35 per share were in the middle of the original guidance range. This was achieved despite the disruption from pandemic related lockdowns in several markets as well as severe weather that impacted our operations in Texas, Oklahoma and Mexico. In fact, performance was strong across all key business metrics after excluding the impact of severe weather and related elevated energy cost.

Higher prices more than offset underlying inflation and core sales volume was up around 1.5%. Importantly, favorable demand trends accelerated as we progress through the quarter. Likewise, earnings benefited from the combination of very good operating performance and our margin expansion initiatives. In fact, these efforts more than offset the operational impact of severe weather. Finally, cash flow was favorable compared to historic trends reflecting continued very good working capital management.

On top of a strong operating performance, I'm very pleased with the progress we made advancing our strategy. In fact, I believe O I reached an important inflection point. As you've seen over the past several quarters, we have demonstrated step change in our ability to consistently perform and deliver on our commitments. This was achieved despite a very difficult backdrop which underscores the improved resilience of our business and demonstrates improved agility. At the same time, we are removing the constraints of the past and we are successfully advancing breakthrough innovations to create a new future for O I.

Just in the last few weeks, we reached an agreement in principle on a fair and final resolution of our legacy asbestos related liabilities. And we successfully started up our first full scale Magmaline. We expect these and other strategic actions will usher in a new period of prosperity for OAC. I'll expand on that in a moment. As we look to the future, we remain optimistic about our business outlook.

We expect second quarter adjusted earnings will approximate $0.45 to $0.50 which is a significant improvement from the prior year, which was the most disruptive period of the pandemic. Furthermore, we are reiterating our previously communicated full year guidance despite the headwinds during the first quarter. Let's move ahead to Slide four to discuss recent volume trends. As you can see on the chart, demand has been relatively stable over the past fifteen months except for the second quarter of twenty twenty, which was the onset of the pandemic. As I mentioned, our first quarter twenty twenty one shipments were flat with last year, but up around 1.5% excluding the temporary impact of severe weather.

In fact, nearly all markets improved on an adjusted basis. In The Americas, shipments were down 1.3%. However, adjusted for the severe weather underlying demand was up about 1.5%. Volume was up mid single digits in Brazil and the Andean markets. Underlying demand was up low single digits in North America and down slightly in Mexico given capacity constraints.

Shipments were up 2% in Europe. Demand was sluggish earlier in the quarter due to elevated lockdowns and some supply chain corrections. However, trends improved significantly as the quarter progressed and we were up low double digits in March. This improvement was broad based and the only exception was mineral water, which was soft given curtailed restaurant and hotels activity. As we have discussed in the past, demand for healthy sustainable glass containers has remained strong despite significant swings in on premise and retail channel activity.

We have shared some additional insights in the chart on the right. It illustrates the expected trends in food and beverage consumption by channel before, during and after the pandemic. Naturally on premise dropped during the pandemic but was substantially offset by strong retail sales. Going forward, consumption is expected to remain elevated at the retail level while there should be a strong rebound in on premise consumption. Overall, total consumption is expected to increase modestly given changing market dynamics and heightened social activity post pandemic.

In particular, we expect double digit demand growth compared to 2020 levels as we lap the onset of the pandemic. In fact, shipments are up more than 20% month to date in April. So we are off to a good start. Barring any unexpected developments, we now expect demand this year will be up between 3% to 4% from 2020 as shipments recover back toward 2019 levels with further growth to come. Let's turn to Slide five.

In addition to solid underlying performance, we also achieved a number of key milestones during the first quarter as we continue to advance our strategy. On this page, we list our 2021 priorities as well as provide some highlights for the first quarter. I'll touch base on each of our three platforms. First, we aim to expand margins. We have targeted $50,000,000 of gross initiative benefits as well as continued performance improvement in North America.

We have made good initial progress. Initiative benefits totaled $35,000,000 during the first quarter as we accelerated efforts given the impact of severe weather. I would like to emphasize how well the company did responding to the weather and energy issues. Within the span of two weeks, we curtailed and restarted operations across several large plants which amounted to around 19% of our global capacity and did so with minimal operating and asset issues. While disruptive, this outstanding response is an indicator of the improved resilience and operating agility on a sustained basis in North America and Mexico.

Likewise, it reflects the positive impact of the manufacturing and engineering capabilities we have been developing across the enterprise. Next, we seek to revolutionize glass. To support this, we expect to validate the Magma Generation one design in Germany, advance our glass advocacy campaign and reposition ESG. First, we are pleased with our progress on Magma and we had a very successful startup of our new Magma line in Hosmingen, Germany. This new line is already generating high quality glass bottles and further testing will be conducted over the next few months.

Likewise, we will be training and then transferring the line to a local plant personnel as we target commercialization of this new line by mid year. Our glass advocacy campaign aims to rebalance the dialogue about glass. Efforts are well underway with around 110,000,000 impressions during the first quarter as part of our digital campaign. Like MAGMA, we are very encouraged by the positive response and progress made and we'll continue to advance these efforts. I'll touch on ESG momentarily.

Third, we will continue to optimize our structure. This includes a number of efforts ranging from portfolio adjustments, improving the balance sheet, simplifying the organization and addressing legacy liabilities. Regarding our divestiture program, we have completed about $900,000,000 of asset sales program to date. So we are about 75% of our way towards our revised target of $1,150,000,000 by the end of twenty twenty two. Currently, we have several land sales that are in advanced stages and a number of other efforts continue to move forward.

As we look to grow the business, we recently announced our intent to invest $75,000,000 to profitably expand in The Andeans where we are currently capacity constrained. This will be funded primarily by divestitures and will not alter our debt reduction plans. As John will expand, our first quarter cash flows were quite favorable given historic seasonal trends for the business reflecting very good working capital management which will support debt reduction. Over the past year, one of our top priorities has been to establish the right organization for the future. Our goal is to enable an organization that is simple, agile and effective to help us consistently deliver on our commitments.

This effort continues. Last month we entered into a long term strategic agreement with Accenture to manage our global business service activities. In addition to reducing SG and A cost, we expect to accelerate capability enhancement by leveraging world class processes and technologies. Finally, we announced on Monday that our subsidiary, Paddock Enterprises LLC has reached an agreement in principle for a third and final resolution to our legacy asbestos related liabilities. Specifically, PATROC agreed to a mediator's proposal for a consensual plan of reorganization regarding the PATROC Chapter 11 filing.

The agreement provides for total consideration of $610,000,000 to fund a trust on the effective date of the planned reorganization subject to documentation and satisfaction of certain conditions. This is a major milestone. O I has paid $5,000,000,000 in Adesto related claims over forty years. Just in the past decade, these payments have consumed 40% of our cash flows. With this agreement, we are turning a new page where we can place all of our focus and resources to enable a prosperous future for O I and all its stakeholders.

Overall, we are very pleased with our progress and I want to thank the OI team for their tireless and effective effort to advance our strategy. Before I turn it over to John, let me add a few comments on sustainability. More than ever, consumers are looking for healthy choices both for themselves and the planet. As we say often, glass is made from natural ingredients. It won't harm us, the earth or the oceans.

Unlike other packaging, it is already 100% recyclable and it can be recycled endlessly. This is why consumers have long viewed glass as one of the most air friendly package. Despite what you might hear, this still holds true today. Looking on the right side of slide six, you will see the result of a recent survey by McKinsey that evaluates consumer views of packaging sustainability which confirms what consumers have long believed. While views do range by geography, glass is viewed as a highly sustainable packaging option across most of the markets.

In fact, it ranks in the top three across the majority of geographies. Importantly, glass is perceived by consumers as much more sustainable than metal containers such as aluminum cans. This underscores the importance of our ongoing glass advocacy campaign as we seek to rebalance the discussion around packaging substrates and sustainability.

Speaker 3

Now over to John. Thanks Anders and good morning everyone. I plan to cover a few topics today including recent performance, progress on our capital structure, as well as our most current 2021 business outlook. I'll start with a review of our first quarter performance on Page seven. OI reported adjusted earnings of $0.35 per share.

Results were at the midpoint of our guidance range, but down from $0.41 last year, reflecting recent divestitures. Overall, very good benefits from our margin expansion initiatives nearly offset the impact of severe weather. Despite the disruptions during the first quarter, segment profit of $175,000,000 was comparable to last year. Severe weather impacted results by around $40,000,000 including lower sales and production levels and elevated energy costs that reflect our estimate of expected energy surcharges from this event. On the other hand, initiative benefits of $35,000,000 were better than expected as we accelerated margin expansion actions in light of the challenge of severe weather.

While cost inflation exceeded the benefit of higher selling prices, this was all attributed to weather related energy surcharges. As Andres noted, sales volume was flat with the prior year, but up around 1.5 excluding the weather impact. For very good operating performance, our margin expansion initiatives and other cost actions more than offset the operating impact of severe weather. The slide includes additional details on non operating items. Overall, we are pleased with favorable underlying performance trends.

Moving to Page eight, we have provided more information by segment. In The Americas, segment profit was $100,000,000 compared to $103,000,000 last year. As noted, earnings were impacted by the severe weather including related energy surcharges. While shipments were down slightly, underlying demand was up about 1.5% excluding the impact of severe weather. Finally, strong operating performance as well as the benefits from margin expansion initiatives more than offset weather related costs.

In Europe, segment profit was $75,000,000 compared to $61,000,000 last year. Half of this improvement reflected favorable FX. While the region began to implement annual price increases, cost inflation was elevated, especially energy related costs. This was offset by higher sales volumes, which increased 2% from last year. Improved earnings were driven by favorable operating performance, including benefit from our margin expansion initiatives.

Keep in mind that we no longer report an Asia Pacific region following the sale of ANZ last summer. Let's shift to cash flows and the balance sheet. I'm now on Page nine. As stated in the past, we are following specific capital allocation principles during the pandemic. As we focus on maximizing free cash flow, we expect significantly higher cash flow this year and key working capital measures should be in line or favorable compared to 2020 levels.

As illustrated in the chart, our first quarter cash flow was a $149,000,000 use of cash. While the first quarter is typically a use of cash given the seasonality of the business, our performance this quarter was considerably better than we have seen in prior years. This reflected significant efforts to improve working capital management and consistency. For example, IDS was down eleven days from the same period last year and we now maintain our AR factoring activity to between 35 receivables. Going forward, we expect cash flows would be more radical over the year.

Second, we preserved our strong liquidity and finished the first quarter with approximately $2,100,000,000 of liquidity, well above the established floor. Third, we are reducing debt. We expect net debt will end the year below $4,400,000,000 and our BCA leverage ratio should get in the year in the high threes compared to 4.4 times at the end of twenty twenty. Further divestitures will improve this position. Please note these targets could shift if the Paddock trust funding occurs prior to year end.

At the end of the first quarter, net debt was down around $900,000,000 for the same period last year, reflecting improved free cash flow and proceeds from divestitures despite unfavorable FX. During the quarter, we did receive the final $58,000,000 in proceeds on the ANZ divestiture, which was used to reduce debt. Furthermore, our leverage ratio was around four times, which is well below our covenant limit of five times. Finally, we intend to derisk legacy liabilities as we advance the Paddock Chapter 11 process. As Anders noted, we have an agreement in principle for a consensual plan of reorganization whereby OI will support Paddock's funding of a five twenty four gs trust.

Total consideration is $610,000,000 to be paid at the effective date of the plan. Importantly, the agreement the agreement provides a channeling injunction protecting OI, Paddock and and their affiliates from current and future liability. Timing will be a function of the remaining legal and court actions to conclude this matter. As previously noted, we have ample liquidity to fund this trust in the future and for clarity, we are not considering equity as a funding method. Likewise, we remain highly focused on reducing our total debt obligations over time through free cash flow and proceeds from divestitures.

Let me wrap up with a few comments on our business outlook. I'm now on Page 10. As Andres mentioned, we anticipate our business performance will improve in 2021 as markets recover and stabilize. We expect second quarter adjusted earnings will approximate $0.45 to $0.50 per share. Naturally, this is a significant improvement from the second quarter of twenty twenty, which was impacted by the onset of the pandemic.

The improvement will be driven by higher sales and production volume. With more stable demand, we expect shipments will be up more than 15%, which would be more in line with 2019 levels. Likewise, production should be up more than 20% as we do not anticipate the operating disruption we saw last year given major lockdowns underway at that time. Finally, earnings should benefit from continued operating performance, improved operating performance while some temporary benefits in prior periods will not repeat or are rephased. More details are on the slide.

We are reiterating our full year guidance despite the weather related headwinds in the first quarter. This includes adjusted earnings of $1.55 to $1.75 EPS and free cash flow of approximately $240,000,000 Consistent with prior comments, we anticipate hosting investor events in the near future. We expect that first will be in September after we have validated Magma at Holtzmanen by around midyear. A specific date will be announced soon. During this session, we will update our strategy, provide more details on Magma, including evaluation analysis and preliminary deployment plan.

Likewise, we will share key company targets and milestones. Subsequent investor events will expand on key topics. With that, I'll turn it back to Andres.

Speaker 2

Thanks, John. Let me wrap up with a few comments on Slide 11. Overall, we are pleased with our first quarter performance, which was in line with our original guidance range despite the headwinds from weather issues and the ongoing pandemic. In fact, our underlying performance was favorable across all key business levers. Selling prices and underlying volume were up and costs were down.

Our margin expansion initiatives are working well and our ability to deliver on our commitments has improved. I'm very pleased with the progress we're making on our bold plan to change O I's business fundamentals. Our business is more stable and we are a much more agile organization. As a result, our resilience and performance has improved and we are consistently delivering on our commitments. Likewise, we are removing the constraints of the past like legacy Alvestos liabilities while successfully advancing breakthrough innovations such as Magma.

We expect these and other key strategic actions will pave the way for a prosperous future ROI. Finally, we are encouraged by market trends and expect improved business performance and profitable growth in 2021 and beyond. I continue to believe our best days are yet to come. Thank you for your interest in Eyeglass and we welcome your questions.

Speaker 0

Thank Your first question comes from the line of Ghansham Panjabi from Baird. Your line is now open.

Speaker 4

Thank you. Good morning, everybody.

Speaker 3

Good morning. Good morning.

Speaker 4

Yes. So, you know, Anders, since you last reported, you know, obviously vaccines have been deployed almost exponentially in The U. S, Europe continues to sort of oscillate between lockdowns, and there's been a significant virus flare up in Brazil. Can you give us a sense as to how these dynamics are playing out for you regionally at current and how it's changed your geographic sort of volume mix outlook for 2021 relative to your initial guidance, if at all?

Speaker 2

Yeah. So since we experienced the first wave of lockdowns back in 2020, I think everyone learned how to navigate these times when lockdowns come up. And that's what we're seeing in Europe for example. Lockdowns have been strong. Nevertheless demand is quite high with exception of one product which is mineral water which has been impacted by the lockdowns reducing activity in hotels and restaurants.

Everything else is up. So that has been learned. Have learned that there is a very good resilience of the glass packaging in both channels. So as we've seen channel shifts between on premise and off premise, we've seen a very strong performance in retail giving us then the balance of the drop in on premise. Now we're seeing on premise coming back up in The United States as an example, but we expect that some of the gain that we got in the off premise is going to be retained going forward.

There are good things taking place out there in the various markets. For example, in Europe demand for beer is very strong. Looking at Nielsen statistics for Western European countries, the performance of glass is very strong when compared to alternative packaging for those countries that are relevant to Hawaii. The world dough wine which was soft for that two years in a row is now quite strong and the reason for that is the exports to China are back up again as well as the exports to The United States with the reduction of tariffs. And then when we look at The Americas, demand for beer is very strong and is across all markets including The United States.

And this is highly influenced by the focus of consumers or the preference of consumers for premium products. In the case of Latin America specifically, there is localization of global brands, which is driving significant demand in beer. There is conversion from return orders to one way and there is also entrance of new players in certain countries. Food is strong across all markets in which we operate. And in our case in particular we've been quite successful on boarding new mix in The United States.

So there are plenty of dynamics taking place beyond the lockdowns per se and we're seeing clearly markets like Europe that everyone learn, all the stakeholders learn how to wear those lockdowns.

Speaker 3

I I would just build on that. If you take a look at the demand that we have it, particularly in Latin America and take Brazil where you had mentioned that, you know, there's there's the cases going up, But we're in such an oversold position down in those marketplaces that, to tell you the truth, we're still looking very optimistic about the demand structures those particular markets.

Speaker 4

Okay. That's helpful. And then for my second question, specific to asbestos, relative to other five twenty four gs type bankruptcy cases, the resolution that you announced earlier this week was quite a bit faster than what other companies have been able to deliver upon previously. So what insight can you provide on the timeline of your specific situation? And also, what are the sort of milestones going forward?

Thanks so much.

Speaker 3

Yeah. Sure. I'll I'll I'll address that, Ghansham. As you know, we we entered into this process looking to, you know, establish a fair and final resolution that was a top priority for the for the business. As you saw and and Andres explained, we got a lot of good things going on with the business, and we wanna turn a new, you know, chapter in this.

I I think, you know, after the initial administrative processes with this, you know, we had, you know, a a mediation process with with two very good mediators, at the table there, and and that was a very effective process to bring this to a head a timely manner. So so we really appreciate, you know, all all the effort that went into that. As far as next steps, you know, there are a number of steps to to complete the bankruptcy. Just to give you a little insight of some of the things, there's the drafting of the reorganization plan, the disclosure statements, solicitation, voting materials. There'll be a number of court hearings, and this needs to be approved by both The US Bankruptcy and the Delaware courts.

Overall, we expect this process will be measured in months, but but not years, for example.

Speaker 2

Perfect. Thank you.

Speaker 0

Your next question comes from the line of George Staphos from Bank of America Merrill Lynch. Your line is now open.

Speaker 5

Hi, everyone. Good morning. For the details and good work on the progress so far. Congratulations on that. I guess my first question is on the accelerated cost reduction activity.

Could you put a finer point on how you're able to accelerate? What specific tactics did you work? How much of that is transitory? Will some of it come back into the P and L if it was accelerated in the first quarter? Might we not see that $50,000,000 number if it's not temporary in the first quarter actually prove to be conservative?

And then I had a follow on.

Speaker 3

Yeah. I'll that one, George. First of all, all the savings that we achieved under our margin enhancement initiatives are intended to be permanent savings. Okay? So we accelerated them, but they they aren't going to disappear, for example.

So as we look to the full year benefits of the $50,000,000, we're still very comfortable with that, and and we may see the potential to do a little better than that. So how did things get accelerated? You know, I would say a couple categories where we were able to push things was on the on the labor optimization front is one area that sticks out. So we were able to do more work there. Of course, there's some consumption related areas that that we knew that we could do better at, and and we invoked those particular activity early.

But but, again, those are those tend to be things that are more permanent in nature and not timing related in in that regard. So, you know, $35,000,000, we probably expected about $20,000,000 in the first quarter. So we did about $15,000,000 better than we had anticipated. But, again, those are permanent. So when we think of the second quarter, as we indicated, you know, the actually, the incremental amount of initiative benefits might be modest in the second quarter.

It's not like they flip around. But then as you go into the back half of the year, you start to pick up the steam in that regard. You know, as we look to the total benefits not included in the $35,000,000 we we did have some belt tightening here in in the, second quarter. That might be I mean, sorry, first quarter. That might be in the neighborhood of five to ten million dollars.

You know, that that's part of when we made the comments about some temporary adjustments and everything when we gave our full year I mean, our second quarter guidance of 45 to 50¢. That those will be a little bit lower. And examples of those would be timing of maintenance costs. For example, with the level of activity that had to happen in between Texas and Mexico and things like that, there's a little bit less focus on some of the maintenance activities within the business. So that's just going to happen in the second quarter.

But again, that's different distinct from the 35 that we believe is going to carry forward.

Speaker 5

Thanks, John. A point of clarification and then a question on paddock. Just what is a consumption related area that you invoked a bit more quickly? If you could just sort of say what that is. And then on paddock, again, nice it's to see that you're getting to resolution here.

I recognize we've covered you for a long time. We know how big of a burden it's been to you from a cash flow standpoint over the years. But if we didn't have asbestos, as you studied it, what would be the one or two things that you could do right now that you can't do at the present time given this burden and overhang that you've had, either from a capacity or some other standpoint? And John, as you studied it, what do you think it would do to your cost of capital not having this as a concern for OI going forward? Thank you and good luck in the quarter.

Speaker 3

Okay. Yes. So on the consumption area, there's maintenance comes out, but I wanna distinguish that between maintenance that is the timing element of maintenance. But but how effective we we go out with parts and elements and, you know, spending and indirect spending activities were some of the areas that we can do better at. You know, from a procurement standpoint, activities like that, we we accelerated those to be able to get the cost down and and the consumption a little bit faster than than we thought.

Got it. So, you know, then moving on to some of the asbestos questions there. So, you know, what are some of the things that we're able to do now that we would not have been able to do in the past? Well, I I I think if you look at the leverage of the company overall, it is it is higher than we would like, primarily because we just you know, historically, haven't had the cash flow to be able to work down the debt and things like that. So clearly, our op one of our opportunities is to to delever the company at a rate that we wouldn't be able to do otherwise.

At the same token, you know, we do have capacity constrained marketplaces that we we refer to now. You know, we we highlighted that when as we work in the the Andeans and the expansion there, we're gonna be funding that through through, additional divestitures. But as we look to the future, you know, that is a primary area to be able to go, to to be able to look at. And and, of course, we're very excited about, you know, Magma and the prospects there and being able to have the right balance sheet in place in in advance of being able to to move that forward are some really important things on our mind of how we would how we would use the use the cash. And then your last question was was was cost of capital for the organization.

And that's a bit of a tricky one. You know, what what I would say is that, you know, the the equity cost of the business has has, I mean, the equity value of the business has been a little bit, you know, reduced as a result because of the overhang of asbestos, at least we believe. So I think there'll be a rebalancing. Ideally, that there'll be market more market capitalization in the business as this liability goes away. But as we are able to service debt and reduce and improve our balance sheet, I think our debt debt load and and carrying cost of debt will go down a lot too.

So there's lot of moving pieces in that, and hope hopefully, those give you some additional insights.

Speaker 5

Thank you, John.

Speaker 0

Your next question comes from the line of Anthony Pettinari from Citibank. Your line is now open.

Speaker 6

Good morning. Good morning. Your guidance for 2Q has pricecost as neutral. And I just wondered if you could parse that out a little bit, specifically in terms of passing through some of these costs like freight that have spiked up pretty quickly. Are you doing special price increases?

Or it just seems like some of your peers are probably not going to recover some of these costs until maybe the second half. So just wondering how you get to sort of neutral price costs so quickly.

Speaker 3

Yes. So so, you're you're right. Our our our guidance is basically to have neutral, price inflation spread. Now our original guidance for the full year, just for for clarity, is to have some pressure there. We we do we do anticipate in the back half of the year that that spread will be a little bit of a pressure.

What we're seeing is that the ink price increases that we have for the year, so for example, in the first quarter, you know, prices were up about 2% or so. That that is at a rate a little bit higher than the rate at which we're seeing inflation increase. Now we do anticipate that to start picking up. As you mentioned, you know, logistics costs and freight and some of the energy categories are particularly The US has some some freight pressure. But we got a good start to the pricing improvements in the beginning of the year, so so that's moving forward.

You know, one of our margin expansion initiatives, as we've referred to it, is is our revenue optimization program. And there's a lot of value based pricing included in that, and that's going quite successfully for the organization, and that's contributing to some of the ability to manage through the front end of of the beginning of the cost inflation. We continue to expect that to improve, but but the some of the cost inflation will will start to mount for the year. Now as we look at inflation overall, we are seeing it going up. But, keep in mind, last year was record low inflation.

We expected increased inflation this year, but it's a little higher than we thought, but still probably at or below a normal year of inflation for the company. So the the type of dynamics and the PAFs and the pricing activities in the wood business can can manage through it at least for the next quarter or two.

Speaker 6

Okay. That's very helpful. And then you talked about sold out conditions in The Andes and I think Brazil. Is it possible to quantify maybe how much volumes you've left on the table, whether it's zero five point in The Americas or one point or something like that, where that you could have otherwise have met?

Speaker 0

And then is there any sort

Speaker 6

of general thoughts around CapEx needs in 2022 plus based on some of these opportunities?

Speaker 2

Yes. It is difficult to quantify the volume that we are not enjoying at this point in time because of being capacity constrained. But what we can say is in every one of those countries, if we have more capacity today, we will be selling more. So what we're doing is we are evaluating opportunities and seeing what needs to be moved forward. But we always have we've been saying very clearly that our priority is free cash flow and the re auction.

So as a consequence of that, we're looking at tactical divestiture opportunities beyond the targets that we initially established to be able to redirect funds to those opportunities.

Speaker 6

Okay. That's helpful. I'll turn it over.

Speaker 0

Your next question comes from the line of Saul Kiana from Seaport Global. Your line is now open.

Speaker 7

Yes. Hi. Thanks for taking my questions. So firstly, I was wondering on the divestiture program that you have another two fifty million dollars including the land sales that you have line of sight to. Are there any other nonoperating, I guess, nonincome generating assets that you can, that you can divest besides the $50,000,000 that you discussed?

Speaker 3

Yeah. I I think there is, Sal. Yeah. For that 250,000,000 or so left to go, it will be a mixture of land sales. I I think the land opportunity is above the $50,000,000.

Maybe one way to look at it is that if you blend, the the divestiture of of land sales that don't have any EBITDA leakage as well as some of the operating side, you're probably looking at a 10 times multiple on EBITDA as far as what we think is the net effect of all of this, understanding that, you know, operating assets are gonna go at certain multiple and then you don't have any EBITDA leakage on on the land sale side.

Speaker 7

Okay. Great. That's that's very helpful. The other thing I wanted to, to understand is, with regard a little bit the sustainability, you know, you mentioned about the perception of glass, and certainly it's, infinitely recyclable. But what progress are you making, and what do you see the perception in terms of actually having glass re being recycled?

And the reason I'm asking that is because I think even your kind of hometown of Perrysburg, recently, it was announced that they're stopping the they're accepting glass, and I guess you guys are going to accept the glass from consumers at specific locations. But still, that is clearly a hurdle to have in higher glass recycling rate, you know, that town, but also globally as we think about, you know, glass being recycled.

Speaker 2

Yeah, so the recycling rates in Europe are very high, if not the highest. So we have that experience with us which we intend to leverage as we move forward. Recycling rates in The United States are not as high. And obviously we've got to make a significant change in the system in this country. It's not an easy task to accomplish.

However, we're taking several actions in different fronts to address it. One of them is, for example, the GPI and its members put together a roadmap for recycling expansion with very clear targets and the Boston Consulting Group supported that effort. That's now under execution. We haven't seen that in a long time as far as I remember. We we've been exploring solutions for a separate stream collection based on the experience in Europe and we are running some pilots about that.

We are deploying a program that we call Glass for Good, which converts glass collection into value communities. For example, to improve education in the communities. We are working on close loop systems with our customers too. And overall we are rebalancing the dialogue and increasing awareness of our glass benefits and in particular we are working on educating communities about the actual value of glass recycling.

Speaker 7

Great. Thank you very much.

Speaker 0

Your next question comes from the line of Mike Lighthead from Barclays. Your line is now open.

Speaker 8

Great. Thanks. Good morning, I guess, first, two on the Paddock funding mechanism. One, is there a rough expectation yet when you would expect to commit the funds? And two, should we expect one lump sum payment or a series of two or three contributions?

Speaker 3

Yeah. So for for clarity on the time it it it goes back to what I had mentioned before is that there's a series of activities that have to go out, have to occur, be able until the plan gets confirmed. The last stages of those, as I mentioned before, is the the final approval by the US bankruptcy court and the Delaware court. And so, you know, that is a so the whole process is gonna be paced by that. And as I mentioned before, this is gauged in in months, but but not years.

So so we we think it'll happen reasonably quick. As far as the timing of this, you know, the the the, the consideration is is due at the end, once we come out of the, out of that plan and the bankruptcy courts approve it. But as we as I mentioned earlier on, is this is agreement in principle. There's a lot of stuff that has to be, written up and documented and and worked out in that regard. But but, we would anticipate at this point in time that it follows quickly thereafter.

Speaker 8

Okay. And we we should expect one lump payment at the time, or would it be like a payment series of two or three contributions?

Speaker 2

You know, let let's let's deal with that in

Speaker 3

the future a little bit. But at this point in time, we would anticipate it would happen very quickly after the plan confirmation.

Speaker 8

Got it. Fair enough. And then for my follow-up, just a question, maybe if I could reference Slide four. I just want to make sure I'm reading that correctly. Is 3% to 4% volume growth still your expected full year volume growth?

And if it's not, what's the current, full year expected shipment growth and what that expects implies for the back half of the year? Thank you.

Speaker 3

Yeah. Yeah. Sure. You know, our original guidance going into the year back in February was up to be to be up 2% to 4%. So 3% to 4% is we've that in in you know, from that time and and improved the overall outlook for the year.

So, you know, our volumes are essentially flat here during the the first quarter, as we mentioned. The second quarter, if we're up in that 15% plus range, that that equates to, you know, a three to 4% kind of annualized increase. And so in the back half of the year, that would imply fairly stable demand. The one thing that we don't know is we're we're seeing some good strong demand here, but, you know, how how are supply chains looking? And and, will will there be, you know, some, you know, supply chain adjustments in that regard, and also the capacity that we have within our business to be able to to meet further demand as as we work through things.

You know? So that's our base best estimate right now, and we'll continue to update the market as we see things progress around midyear.

Speaker 2

Great. Thank you.

Speaker 0

Your next question comes from the line of Kyle White from Deutsche Bank. Your line is now open.

Speaker 9

Hey. Good morning. Thank you. I just wanted to go back to your biz your business update that you provided back in February just to make sure I understand. So when you pointed to earnings being below your guidance and then now actually coming in line with the original guidance, I mean, a $40,000,000 weather impact is pretty severe.

So so was March just much better than what you're expecting there in mid in mid February, or was it all driven by accelerating some of these margin expansions that that you talked about?

Speaker 3

I I I it's a combination of both. The the volumes were definitely better in in March than than we were we were originally expecting because at the time that we had given that kind of update on guidance in in in, you know, mid quarter or so, we had indicated we thought volumes as a result were gonna be down, but they ended up being flat. So so that represents a marginal increase in in the volume activity, but also the the cost performance, was was very strong. You know, we the the weather hit us in February, and the team got working very quickly and effectively in the March period to take a lot of costs out.

Speaker 2

Yeah. And I think it is important to mention that the program that we have, for example, to address cost of goods sold is called total system cost. This has been in implementation for about three years now. So it's fairly mature. And this covers cost across the entire system.

It connects the organization top down and across. It has a very good structure, information systems, very clear targets. So we have a pretty strong capability that was developed over time. And I think now we're enjoying the ability to influence cost in a pretty important manner. And I think you're seeing the impact of that.

Speaker 9

Got it. And then are you gaining any traction with customers in the hard seltzer category? Is there an opportunity in Europe as maybe some brands start to penetrate that market or maybe an opportunity to kind of premiumize existing brands here in The US or maybe target premixed cocktails in both regions?

Speaker 2

Yes. We are. And, obviously, we cannot comment about them because they're in development. But yes, there is increased activity. In fact, the glass advocacy campaign that we're moving forward is calling the interest of both consumers and customers.

And we see it, for example, reflected in the leads that were

Speaker 0

Excuse me. This is the operator. There has been a technical issue with the line of the presenters. I'll reconnect them now. Speakers, please speak Yes. To

Speaker 3

Sorry, we had some technical difficulties. Something dropped.

Speaker 1

Do you wanna continue with your question?

Speaker 9

Yeah. I mean, I'll ask it again, but I was just asking asking about the the opportunity with hard seltzers, you know, in The US and Europe. And understanding that you can't comment on any future commercial developments, but maybe talk about, you know, if you see any more opportunity in Europe versus The U. S. Or anything of that nature.

Thanks.

Speaker 2

Yeah. So there is increased interest by customers across markets in putting hard seltzers in glass and oil products, adjacencies of beer and oil products. The new product development activity has increased. The glass advocacy campaign is starting to create an interest in consumers and customers. And for example, we use C4C as CRM in our organization and we have seen the leads in that C4C system increase as a consequence of some of the latest campaigns that we move forward.

There is significant value in glass related to branding and supporting brands, supporting premium products and we are seeing that incrementally recognized by customers and then moving forward with some of the clients.

Speaker 3

Just if I could, I wanted to make one quick this is John. I wanted to make one quick clarification to a question from Mike earlier because I realized that maybe some of my comments on the timing of of the payment for, you know, the, you know, the Paddock five twenty four funding was a little bit, inconsistent. So let me just clarify. The the terms of the accepted mediator proposal, the $610,000,000 of total consideration, is the fund on the effective date, of the plan confirmation. Of course, there's some, you know, final documentation required and final steps between now and then, but that is the terms set forth in the mediator proposal that we accepted.

So I just wanna clarify that point.

Speaker 1

Okay. Operator, I think we're ready for the next question.

Speaker 0

Thank you. Your next question comes from the line of Mark Wilde from Bank of Montreal. Your line is now open.

Speaker 10

Thanks and congratulations on a good start to the year, headwinds notwithstanding. John, I wondered if you can just talk a little bit about the expectations in terms of the second half. You did beat expectations on the first quarter. Your second quarter guidance is above most estimates, but you've held the full year at existing levels. So I wondered if you can just help reconcile that for us.

Speaker 3

Yes, sure. I mean, as we all know, last was a very disruptive period, and and the the seasonality the typical seasonality of the business didn't play out. But we're seeing a much more reversion back to the norm there, Mark. So so what we have typically seen in our business in the past is the first quarter and the fourth quarter are very consistent with each other. They're both the winter periods and and the, and the, Northern Hemisphere.

And and in the the second quarter and the third quarters are also very consistent with each other, consistent with the the summer, period in the Northern Hemisphere. So so, you know, the the back half of the year will look a little bit like a mirror image of the first half of the year. So I think that that is probably a little bit of reversion back to the norm. Hopefully, answers Yeah. Your

Speaker 10

does. It does. And, Andres,

Speaker 5

I'm just curious. What's the

Speaker 10

recycling rate look like down in Latin America? We talked about Europe. We talked about North America.

Speaker 2

Yes. I think it's at similar levels than The United States. So Americas are pretty much in similar levels.

Speaker 10

So I'm just curious on that. I mean, it seems like there's a little bit of an inconsistency, this push on sustainability, but in Latin America you're selling more one way glass when you don't have recycling.

Speaker 2

Yes, so we are squarely focused on improving the systems in all the countries. And we have acknowledged that the situation in Europe is really strong. The situation in Americas is not as strong. Now we have ways to improve this. We've been quite passive communicating the benefits of GLASS and interesting communities in these efforts.

That is changing. It's not an easy effort, but we're moving it forward.

Speaker 10

Okay. And finally, related to this, can you talk a little bit about the GLASS advocacy work? You called out the incremental expense in the earnings release.

Speaker 2

Yeah, so this is a campaign in social media that is intended to reposition the benefits of glass. We want to rebalance the dialogue around packaging and make sure the benefits of glass are properly positioned and understood both by consumers and customers and stakeholders in general. So we've been very active on that. Part of the reason why things are not as good as you would like them to see in the recycling is because of being passive for quite a while. Well that is changing and we're becoming very active in that front and the glass advocacy campaign is intended to reposition glass work together.

Very important to highlight MAGMA has several important characteristics that are going to support the recycling of glass. And that's something that we're going to talk as we get together in September that the company is actually changing excuse me, actually working to change the fundamentals of that recycling system in the markets where it is low. Because the potential of the product is really high. It's a great product. It's 100% recycled like none out there.

It's highly recycled where the effort has been moved forward. We're going to move forward the effort into places where it's not.

Speaker 10

Okay, very good. I'll turn it over.

Speaker 0

Your next question comes from the line of Adam Josephson from KeyBanc. Your line is now open.

Speaker 11

Andres, John, good morning. Thanks for taking the questions. Andres, one on the updated strategy that you're talking about at the Investor Day. I mean, you've been reducing structural costs pretty effectively for years. You've been working on Magma for years.

You're obviously dealing with the asbestos liability, and hopefully, that will be a thing of the past in the next few months. So I guess I'm wondering what the updated strategy really is. In other words, distinct from what you've been doing consistently over the past two to three years in terms of cutting costs, working on MAGMA, etcetera.

Speaker 2

Yeah. So the we're going to update the strategy in September. So we're going to provide an update to you on that at that time. Now we've been squarely focused developing capabilities in this organization that were needed to perform. And for example, I just described the total system cost, but we also are working on cost initiatives that impact SG and A.

Now it takes time to develop those capabilities. And what we're seeing today is those margin expansion initiatives are leveraging those capabilities that we've built. And as a result, we are effectively impacting margin expansion and earnings expansion. Now we're going to see that building over time even more. We believe those initiatives are multiyear initiatives and the impact of that is still yet to come because we are this is now gaining the momentum.

The Magna development is a major technology development that doesn't happen in a short period of time. We've been several years now into this. Things are going really well. We are producing high quality glass enclosed medium at this point in time. So it takes time.

That you're going to see the value of this technology this effort when we get together in September. And obviously, Paroc and asbestos have been widely covered. It's a very structural move in the organization and we're very pleased with the products.

Speaker 3

The only thing I would add there is is is as Anders talk was talking, Magna is a major development for us. But it's not just a technology. It's how you go to market. And as we've said several times in the past, it's about a new business model for glass. And so I think that opens up a a number of doors that maybe have not been considered in the past for our business.

And so we will I'm sure we'll elaborate on that.

Speaker 11

Got it. Thanks, John. And just back to the the sustainability issue in this McKinsey survey you're talking about. So if I look at this in The U. S.

Consumers think glass is much more sustainable than metal containers, obviously, yet the last ten years, metal containers have been growing at a far more rapid rate than has glass. So if in fact U. S. Consumers view glass as more sustainable, why are they not buying it nearly to the same degree that they are cans?

Speaker 2

Well, there are multiple reasons for that, and, I think we are intended to address all those reasons with the strategy we're moving forward. And one of them is being that we haven't been expanding, for example, at the rate fees could be expanded to take the opportunity this package inherently has. Well, we're making those moves as you see. We just announced an investment in the Andean countries to support that growth. We just made an expansion in Europe in Euroncourt, which was very timely.

It's been selling extremely well from the start and is supporting the past growth of that beer demand in Europe. I just explained to you how in the call that how the demand in Western European countries for glass in the countries that are relevant for us is being strong and better in performance than alternative packaging. So there are many things at play. I think you're looking at things, for with the perspective of where we're coming from. And I think it's important that in our meeting in September, we can explain clearly to you where we're going to, which is reflecting significant changes in our impact in the markets.

Speaker 10

Thank you, Andreas.

Speaker 0

Your next question comes from the line of Arun Viswanathan from RBC Capital Markets. Congrats

Speaker 12

on the progress with asbestos and the recovery as well. I guess my first question is just on the volumes. We have seen some differing data on wine. Have you seen kind of a drop off in wine as we have seen the growth in the seltzer market? What's your kind of overall view on wine as we as we move from here?

Speaker 2

Well, during the pandemic, wine has been growing at a better rate than before. We gotta observe closely what is going to happen once once things normalize. So I I assume you're referring to The United States because the situation in you I said, okay. So so in The United States, that's the situation. It's been better than it was before.

It's primarily focused on premium wines which is where we play the most and that's been the case in the last year. We've got to see what's going to happen after things normalize. And there's still some period of time to be able to get there.

Speaker 12

Okay. And then just on the quarterly kind of cadence for volumes, so I guess maybe you're up 20% in the April. Do you expect that pace to kind of continue through the rest of the quarter? And then do you expect kind of negative growth in Q3, Q4 to get you to that 3% to 4% for the full year? Or how are you thinking about the evolution of volumes as you move through 'twenty one?

Speaker 2

Well, things are still quite volatile across supply chain. So it's very difficult to make a prediction of volume and what it is going to be. I think what we're seeing in April is a pretty good data point, but it's difficult to extrapolate that data point to the quarter or the year at this point in time. So we got to stay close to markets. I think you're seeing this in multiple companies.

Volatility is high. Even it could be even involving more elements than it did a year ago in terms of drivers of volatility. So at this point in time, the first quarter worked out well for us from a demand standpoint with the exception of the severe weather impact. April has been very strong and we'll be close to market demand and we'll update you as things progress.

Speaker 3

I I would just build on there. Remember the last year, April and May were kind of your toughest comps with the with the, with the pandemic. So, you know, good strong comp, you know, comparable numbers in April and May are expected. You know, June will probably be little bit more more normalizing as we saw last year. It was starting to normalize, blending out to that 15% plus for the whole quarter.

So that's kind of how we would look, and you gotta consider the comp aspect of this. And keep in mind, we are not, you know, targeting a decline in in volumes in the back half of the year, more more stability. Just just kinda trying to see how the tea leaves work at this point in time, understanding that, you know, there's a lot of reopening activities, and and we'll give an update around midyear about how, how, we look for the back half.

Speaker 1

And, operator, I think we have time for one last question.

Speaker 0

Your last question comes from the line of Gabe Hajde from Wells Fargo Securities. Your line is now open.

Speaker 13

Andres, John, Chris, good morning. I'll try to be quick. Can you comment at all, John, about the tax profile of OI going forward? I guess, two part question. One is, is there any sort of onetime tax benefit associated with funding the trust when that does occur?

And then number two, are the kind of legacy NOLs that were associated with or or the tax shields, you know, with funding that along the way, does that go with the bankrupt entity, or does that stay with OI such that you'll kinda continue to have a kind of a low, tax cash tax rate going forward?

Speaker 3

Yeah. So so, I mean, a a kind of a normalized effective tax rate for us is in the mid, call it, mid to high twenties. It's a little bit elevated this year because of there's just a little bit lower earnings. We haven't fully pulled out of out of the, you know, the the pandemic elements in that regard. I mean, there has been some legislative changes around the world.

I'm thinking of Mexico and and The Netherlands where they where they've kind of been addressing some of the interest deductibility. So that's kinda pushed us up to that mid to high twenties compared to maybe the mid twenties in the past. As you as you think about the tax profile in in reference to the the payment that would be made for the the May fund, you know, that that would obviously be a a payment from OI to Paddock from the support agreement from OI that then Paddock would then make to to that fund. That that obviously, just like any other historic asbestos payment that we have made, provides some relative tax, you know, shield or benefits to the organization. Of course, there's a lot of discussion about, you know, tax proposals under the administration right now and things like that.

So it's hard to put a bead on on how consequential that is, but, you know, we would anticipate that. And and and if, you know, there would be something on the sizable side of of tax, you know, changes, you know, that could be a a beneficial for a couple years for the company when you bring that aspect and legacy NOLs and other tax attributes that we have in the past. So more to come. It's a little foggy out there with what's happening on tax legislation.

Speaker 13

All right. Thank you. And then specific to the second quarter guidance, you guys are producing kind of at a 20% rate and expecting kind of 15 plus percent sell through. If history has taught me anything that production rates are equally, if not more important, to kind of the income statement impact on a quarter to quarter basis. So I calculate that benefit to maybe be, call it, dollars 25,000,000 in the second quarter, again, kind of overproducing versus what you're selling.

And I think I heard you say maybe $10,000,000 of some maintenance that got delayed. So is it not fair to say you're over earning by $15,000,000 in the second quarter, and maybe that's why the second half, know, kind of you're a little bit cautious on it? Or and I guess another way I'm thinking about it is if I were to annualize kind of that $0.45 to $0.50 rate, I get to 1.8 to $1 kind of normalized earnings potential, if you can give us any pointers there.

Speaker 3

Yeah. I mean, you know, there's a lot to unpack there. But what I would say is is, you know, one on an annual basis, 1% of volume growth is generally worth fifteen to twenty million dollars to us. 1% of production improvement is probably closer to 20%. So so you can calibrate where things are at.

Actually, you know, on a what what you're seeing is more of a comp from the prior year issue than anything else. Because frankly, our our production and sales volumes right now are very consistent with each other, and we continue to see a stable to improving overall demand environment. So it gets a little wonky from quarter to quarter. But, you know, you know, you know, look at it that way rather than maybe necessarily just just looking at from a comp standpoint in the prior year. And to your full year component, you know, the annualization of 45 to 50¢, the only issue would be the seasonality

As I mentioned, the first and the fourth quarters are a little bit seasonally weaker, whereas you see that strength coming in the in the, second and third. So hopefully, that is helpful. That's there's a lot of elements involved in

Speaker 2

that. Thank you, guys.

Speaker 1

Thanks. And okay, that concludes our earnings call. Please note that our second quarter conference call is currently scheduled for August 4. And remember to make it a memorable moment by choosing safe, sustainable glass. Thank you.

Speaker 0

This concludes today's conference call. Thank you for participating, and have a wonderful day. You may all disconnect.