Spirit AeroSystems - Q4 2022
February 7, 2023
Transcript
Speaker 0
Morning, ladies and gentlemen, and welcome to Spirit AeroSystem Holdings, Inc. 4th Quarter and Full Year 2022 Earnings Conference Call. My name is Glen, and I will be your call I would now like to turn the presentation over to Aaron Hunt, Director of Investor Relations. Please proceed.
Speaker 1
Thank you, Glenn, and good morning, everyone. Welcome to Spirit's 4th quarter and full year 2022 results call. I'm Aaron Hunt, Director of Investor Relations. And with me today are Spirit's President and Chief Executive Officer, Tom Gentilly Senior Vice President and Chief Financial Officer, Mark Cichinski Executive Vice President and President of Defense and Space Division, Duane Hawkins and Spirit's Executive Vice President, Chief Operating Officer and President of Commercial Division, Sam Marnick. After opening comments by Tom, Duane and Mark Regarding our performance and outlook, we will take your questions.
Before we begin, I need to remind you that any projections or goals we may include in our discussion today are likely to involve risks, including those detailed in our earnings release, in our SEC filings, in the forward looking statement at the end of this web presentation and referenced in our call today. In addition, we refer you to our earnings release and presentation for disclosures and reconciliation of non GAAP measures we use when discussing and our results. And as a reminder, you can follow today's broadcast and slide presentation on our website at investor. Spiritarrow.com. With that, I would like to turn the call over to our Chief Executive Officer, Tom Gentile.
Speaker 2
Thank you, Aaron, and good morning, everyone. Welcome to Spirit's 4th quarter and full year 2022 results call. Last year, we saw domestic travel continue to recover across the globe. The U. S.
Was the best performing market where air traffic was 2% below the 2019 level. And in China, we were encouraged to see some travel restrictions lifted and the 737 MAX returned to service. Domestic air travel favors narrow body aircraft like the A320 and the 737 MAX, both of which logged several significant new orders during the year. The orders and additional backlog provide support to Airbus and Boeing's plans to increase narrow body production rates further. We are encouraged by the continued demand, which we expect will benefit Spirit since 85% of our backlog is tied to narrow body aircraft.
While demand remains robust, we experienced a number of challenges as we increased production rates during 2022. We had to hire a significant number of new employees who are taking time to reach the same level of proficiency as the workers we had prior to the pandemic. We also experienced higher levels of attrition with the new employees we hired. In addition, our suppliers encountered similar challenges, which resulted in higher levels of part shortages throughout the year. We also encountered higher levels of inflation.
Despite these challenges, we managed to increase our production rates across several major programs by 27% overall. On the 7 37 program, we managed through the challenges as production increased from 162 units in 2021 to 281 units in 2022, a 73% increase. To support the recovery and the expected higher level of production in 2023, we began hiring additional headcount in the 4th quarter, which drove additional cost, but as an investment to get ready for the production rate increases in 2023. While we expect to see ongoing supply chain challenges and issues as we stabilize production, Our December 7 37 production was 40 units, demonstrating our capability to produce at higher rates. In 2023, we plan to produce about 420 737 shipsets, which includes the units behind schedule from 2022.
In January, we delivered 30 three 737 units. Turning to our wide body programs. The 787 program navigated through challenges last year and we delivered 20 units to our customer. Our 787 production resumed with a new build process to address the fit and finish requirements applicable to all the partners on the program. After completing a few units with the new process, we have found more labor per unit is needed than originally expected, which is one of the reasons driving an additional forward loss on future units this quarter.
Is also taking us longer than we expected to rework the storage 787 units. We now believe we have incorporated what is needed for the 787 fit and finish requirements in the new build process and rework. On our A350 program, we continue to see disruption driving increased cost pressure. During the year, we saw continued disruptions from the supply chain. The transfer of parts and the ramp up of production put the program behind schedule.
We have initiated our recovery plan. However, recovery costs included expedited shipping of components to support our customers' production are resulting in an additional forward loss. Mark will walk you through the details of the forward losses on these two programs in his section. We continue to support Airbus on their narrow body programs. Our production was in line with demand from Airbus and we expect to continue to produce to remain in sync with their production plans.
In 2023, we plan to produce between 650680 A320 units and about 80 A220 units. And looking at our wide body programs for 2023, we will support our customers as they increase their production rates to support the international traffic recovery. On the 787 program, we expect to produce between 4045787 shipsets. On the A350 program, we plan to remain in sync with Boeing excuse me, with Airbus production as they increase from 5 to 6 aircraft per month and plan to produce about 60 units on the A350. Now let's turn to our defense and aftermarket businesses.
On defense and space, Our segment President, Duane Hawkins is retiring from his current role in just a few weeks and will hand off the segment to Mark Miklos. Duane and the team have done a great job in building Spirit's Defense and Space segment, and we wanted to give him an opportunity to take you through some of the many highlights from 2022.
Speaker 3
Duane? Thanks, Tom. In 2022, the Defense and Space team did a really good job executing on existing programs and winning some new ones. Across our five growth areas, hypersonics, UAS, next generation effects, next generation aircraft and space, we expanded relationships with current customers and created some new ones. The Defense and Space segment revenues were up a little over 11% from 2022 to $650,000,000 with approximately 11.2% margin.
We had solid contributions from the P8 and KC-forty six programs. On the CH-fifty three ks program, we began preparing for full rate production by developing our rate production tooling and manufacturing build plan, while also delivering LRIP units. And in December, we had the opportunity to attend the B-twenty one unveiling to celebrate the team's contributions to this important new defense platform. Spirit is one of the 7 partners on the B-twenty one program. We have a strong pipeline of defense and space opportunities that we continue to pursue.
In 2022, the team won multiple classified and unclassified programs that could eventually result in significant revenue for Spirit. 1 of the first in the year was a win for the B-fifty 2 commercial engine replacement program, where Spirit will build the struts and the cells for approximately 78 aircraft that are in service. We were also selected to support the KC-one hundred and thirty five horizontal stabilizer program, which will help extend the life of an aircraft we often see gracing the skies here in Wichita. Another win in the year was the strategic partnership agreement for the Sierra Space Shooting Star Cargo Module. In addition to the Shooting Star, Sierra Space and Spirit will work together to advance a family of cargo modules and service modules.
And finally, we are closely monitoring the protests of the Army Flora Award to our partner Bell Helicopter and look forward to supporting them on this exciting new program. Spirit is proud to be a member of Team Valor. The Spirit National Defense Prototype Center, NDPC, continues to support development, prototyping and industrialization capabilities to support our growth strategy. In addition to the NDPC, we have continued to repurpose some of our excess wide body capacity to defense applications. So far, approximately 1,200,000 square feet in Wichita has been transitioned to our Defense and Space business.
This includes the establishment of our Defense Manufacturing Center, which will provide significant classified machining capability with full size determinant assembly accuracy. The ability of our team to be involved from the initial concept design to production is critical to optimizing how we can support customers on future programs. We closed out the year with the acquisition of Team, a small company in Rhode Island that has a great set of technologies that complements our capabilities. The 100,000 square foot facility and the 35 talented individuals bring some unique 3 d composite weaving technology and equipment to enhance our portfolio that will support hypersonic weapon development as well as other new product development opportunities. I'm proud of the Defense and Space business that we've been building at Spirit.
It's on track to our target of $1,000,000,000 Defense and Space revenue by 2025 with 12% to 14% segment margins. And I look forward to working with our new Spirit and Defense and Space leader, Mark Miklos, as he takes over on April 1. Back to you, Tom. Thanks, Wayne.
Speaker 2
Our aftermarket business also had a strong year with revenue growth of 30% at 19% margins. The aftermarket team continued to build out our strategy to expand our MRO capabilities in key geographic regions. In Asia, we established multiple ways to support customers in that region. In April, we signed an agreement with Gammaco to be the Spirit authorized repair center in China. Then in September, we formed a joint venture with Evergreen Technologies Corporation in Taiwan and signed an MoU with Malaysia Airlines, Burhead to establish repair services for nacelles and flight control services.
We also signed a partnership with Boeing to provide repair services for the MAX on flight control surfaces, nacelles and thrust reversers. We closed out the year with an MoU with DuraAmco, the engineering arm of Dubai Aerospace Enterprise to explore how to bring a range of composite and metallic aerostructure repairs and services to customers in the Mideast region. We continue to target $500,000,000 of revenue for our aftermarket business with margins in excess of 20% by 2025. I'll now turn it over to Mark to take you through more details on our results. Mark?
Speaker 4
Thank you, Tom, and good morning, everyone. We experienced significant pressure in 2022 due to production schedule volatility, a constrained supply chain, ongoing inflation and labor pressures including shortages, high levels of attrition and increased training for our new hires. These challenges have resulted in higher than anticipated costs and disruptions in our factories. We expect some of these pressures to continue into 2023, particularly those related to the supply chain and training new employees. We entered 2023 strongly focused on execution and getting our factories and people in place to stabilize and support higher production rates.
Now let me take you through the details of our 2022 financial results. Let's start with revenue on Slide 2. Revenue for the year was $5,000,000,000 up 27% from 2021. This improvement was primarily due to higher production on the 7 37, A320 and A220 programs, as well as increased aftermarket and defense and space revenue, partially offset by lower production on the 747 and 787 programs. The Defense and Space segment had a strong year with tomline growth of 11%, increasing revenue by about $65,000,000 Aftermarket also displayed strong execution with revenue growth of 30% over 2021 levels.
Turning to deliveries. Overall narrow body deliveries 2022 were 37% higher than 2021. We delivered 119 more 737 units and 124 more A320 units compared to 2021. Alternatively, Wide body program deliveries were down 6% compared to 2021, mainly driven by 17 less 787 units in 2022. Overall, 2022 deliveries increased 27% year over year.
Now let's turn to earnings per share On Slide
Speaker 2
3,
Speaker 4
we reported earnings per share of negative of $5.21 compared to negative $5.19 in 2021. Excluding certain items, Adjusted EPS was negative $2.81 compared to negative $3.46 in the prior year. Operating margin was negative 6% compared to negative 12% in 2021. The improvement over 2021 is due to higher production rates, specifically on the 7 37 program, partially offset by continued disruption in our factories resulting from part shortages and labor challenges, which led to out of sequence work and operational instability. Full year forward losses totaled 250,000,000 and unfavorable cumulative catch up adjustments were $28,000,000 This compared to $242,000,000 of forward losses and $5,000,000 of unfavorable cumulative catch up adjustments in 2021.
Specifically related to the Q4 of 2022, we incurred $114,000,000 of forward losses, which were primarily driven by the 787 and A350 programs. The 7,875 loss of $38,000,000 recorded in the 4th quarter was largely driven by higher cost estimates related to restarting the factory and ramping production as well as new build requirements on each unit resulting from the fit and finish issues. We forecast the cash impact from this loss to occur over the next 4 years. The A350 charge of $667,000,000 in the Q4 of 2022 was a result of additional costs related to labor and part shortages, manufacturing quality issues and additional freight to support our customer deliveries. In addition, during the Q4, we experienced disruption resulting from transferring the production of parts from a supplier into our Kinston facility.
This resulted in additional disruptions to our factory, and we have now initiated a recovery plan, which will result in additional costs. Approximately $40,000,000 of that forward loss will have an impact to cash in 2023. Additionally, in the Q4 of 2022, we recognized unfavorable cumulative catch up adjustments of $59,000,000 primarily driven by the 7 37 and A320 programs. On the 7 37 program, we experienced disruptions due to labor inefficiencies and continued part shortages, which exacerbated behind schedule hours and our out of sequence work. To catch up and prepare for the next rate break, we've made the decision to accelerate the hiring and training of employees to support a rate of 42 aircrafts per month.
This investment has a near term impact on the program's profitability and cash flow, but we believe it is important to improve Spirit's production efficiencies as well as prepare for higher production rates in the future. The A320 program's unfavorable adjustment was driven by operational and supply chain disruptions and increased costs related to material, freight and labor. 2022 earnings also included $157,000,000 of excess capacity costs, a decrease of $60,000,000 over 2021. Other expense was $14,000,000 compared to other income of $147,000,000 in 2021. This variance was primarily due to pension plan termination activities that were undertaken separately in each of the years.
2021 included a curtailment gain of $61,000,000 resulting from the closure of the defined benefit plans acquired as part of the Bombardier acquisition. And in 2022, we terminated the frozen U. S. Pension value plan A, which resulted in non cash charges of $108,000,000 We anticipate additional pretax non cash charge in the Q1 of 2023 for the final settlement accounting as well as tax related charges for the income and excise taxes, which we expect to conclude no later than the Q2. Now turning to free cash flow on Slide 4.
Free cash flow usage for the year was 516,000,000 in line with the range we communicated on our Q3 call. Free cash flow in both years were impacted by several large one time cash items, including a $300,000,000 tax refund received in 2021, a payment of $154,000,000 to the Belfast pension plan in 2021 as well as the repayment in 2022 of 123,000,000 Boeing 737 Advanced that we received in 2019. In addition, 2022 Free cash flow was negatively impacted by production schedule changes, the Ukraine Russian conflict, headwinds from forward losses, labor constraints, supply chain part shortages and inflationary pressures. There were also several other cash items in 2022 that will not recur going forward, including $38,000,000 of a grant received from the AMJP program and $27,000,000 of net pension related benefits from the termination of the pension value plan B. Looking to 2023, we plan to deliver approximately 420 737 units and 650 to 680 A320s during the year, which will be the largest driver of cash flow improvement.
Additionally, 2023 will be positively impacted by $120,000,000 to 140,000,000 of surplus cash from the termination of the pension value plan A, partially offset by higher interest payments and a previously reserved litigation payment, which has been appealed. Incorporating all items, including the pension surplus cash. We are targeting 2023 free cash flow to be better than breakeven, reflected estimated capital expenditures in the range of $125,000,000 to 150,000,000 We anticipate the Q1 free cash flow to be the weakest and cash flow improving throughout the last three quarters of the year, partially due to normal seasonality of our cash flows. With that, Let's now turn to our cash and debt balances on Slide 5. We ended the year with $659,000,000 of cash and $3,900,000,000 of debt.
These balances reflect items I previously listed as drivers to free cash flow, in addition to the $319,000,000 payment to settle the repayable investment agreement in the first half of twenty twenty two and the refinancing activity we completed during the Q4 of 2022, including refinancing and extending maturities on $800,000,000 of existing debt and upsizing by $100,000,000 Now let's discuss our segment performance starting with the Commercial segment On Slide 6. In 2022, commercial revenue was $4,100,000,000 an increase of 30 percent compared to 2021, primarily due to higher production volumes on the 7 37, A220 and A320 programs, partially offset by lower production on the 7 40seven and 787 programs. Operating margin was negative 2% compared to negative 7% in 2021, driven by higher volumes on the 737. As I previously mentioned, the changes in estimates during the year included forward losses of $244,000,000 and unfavorable cumulative catch up adjustments of $30,000,000 In comparison, during 2021, The segment recorded $227,000,000 of forward losses and $6,000,000 of unfavorable cumulative catch ups. The segment had excess cost of $150,000,000 compared to $207,000,000 in 2021.
Additionally, the segment recognized $38,000,000 of charges related to the Russian sanctions, which had an impact during 2022. Now let's turn to the Defense and Space segment on Slide 7. Defense and Space revenue grew to $650,000,000 or 11% higher than 2021 due to higher development program activity and increased PA production. Operating margin for the year increased to 11% compared to 8% in 2021. The improvement was due to higher classified program profit and the absence of non recurring charges taken into 2021.
In 2022, the segment recorded forward losses of $6,000,000 and excess capacity cost of $8,000,000 compared to forward losses of $14,000,000 and excess capacity cost of $11,000,000 in 2021. For our aftermarket segment results, let's turn to Slide 8. Aftermarket revenues were $311,000,000 up 30% compared to 2021, primarily due to higher spares parts sales as well as higher maintenance, repair and overall activity. Operating margin for the year increased to 19% compared to 21% in 2021 due to one time inventory adjustment charges as well as losses of $4,200,000 related to the Russian sanction. 2022 was a more challenging year than we expected.
Production schedule volatility, a disrupted supply chain, labor constraints and ongoing inflation resulted in increased costs, forward loss charges and instability in our factories. Despite the many challenges during the year, there were several things that went right. Many of our financial metrics have reflected continued improvement over the last 2 years, and I expect the recovery to continue going forward. We have announced wins in our Defense and Space and Aftermarket segments. And we have restructured our debt, including executing on refinancing activity, which has extended our maturities and settled a repayable investment agreement.
As we enter 2023, we are working with our suppliers and our internal teams to stabilize production and position ourselves for higher production rates. The focus on operational execution as well as optimizing our costs should enable us to improve profitability and cash flow as we move throughout 2023. Now let me turn it back over to Tom for some closing comments.
Speaker 2
Thanks, Mark. Demand remains strong in the global aerospace industry. However, it was a challenging year to navigate the supply chain and other challenges we faced. We worked hard to make progress to stabilize at higher production rates, and we were pleased to close the year with some positive results, which will provide a strong foundation for 2023. As we enter 2023, we expect free cash flow to be positive as we benefit from increased narrow body production rates and continue to work on improving our labor productivity and stabilizing our supply chain.
We have seen some improvements from the depths of the pandemic, but expect that there will still be some volatility as the recovery continues. After 4 challenging years since the first MAX crash in 2018, we see some positive trends in the market that will benefit Spirit. Domestic traffic has recovered to 98% of what it was compared to 2019 levels, which will benefit narrow body aircraft production. And 85% of Spirit's backlog is narrow body aircraft. Boeing has said that they do not want to develop a new aircraft until 2,035, which is good news for Spirit since the MAX and all of our other Boeing programs will continue for many years to come.
China has started to fly the MAX again. Both China Southern and Hainan have both made flights, which is very good news for that program and offers upside as China brings the stored MAX aircraft out of storage, starts taking deliveries again and then eventually places new orders. Boeing just announced that they're starting a 4th 737 MAX production line in Everett, which highlights their commitment to increasing rates on the MAX and that's Spirit's biggest and most profitable program. And organic diversification in our Defense and Space segments and aftermarket is progressing well. We also have some good growth opportunities in commercial, including freighters for Airbus and Boeing, eVTOL opportunities and other machining opportunities.
For 2023, our 3 primary objectives will be what we are calling the 3 Rs. First, we must realize the production rate increases across all of our programs, while maintaining a safe workplace and improving quality. 2nd, we have to reduce structural cost to position Spirit to be profitable and cash flow positive even if production rates do not go up as fast as currently projected. We have assigned a senior executive and team of leaders to our cost optimization project focused in 3 areas: operations, infrastructure and supply chain. In the infrastructure area, our target is to reduce 1,000 indirect positions from our 2023 headcount plan through a combination of reductions, attrition and closing open hiring requisitions.
3rd, we want to re energize our workforce so that we are ready to meet the challenges ahead as fast as we can as we face the fastest growing rates in the history of the aviation industry. With that, we will be happy to take your questions.
Speaker 0
Thank you. Thank you. With our first question comes from David Strauss from Barclays. David, your line is now open.
Speaker 5
Great. Thanks. Good morning.
Speaker 6
Good morning.
Speaker 5
Free cash flow. So I guess, prior to today, you were seeing better than breakeven without The pension cash gain, now you're seeing kind of better than breakeven, but including that. I guess what changed in terms of your forecast? Because it looks like now $420,000,000 on the MAX would be better than what you were talking about before, which I think was 31 a month. So if you can just help us reconcile what changed now versus your prior free cash flow guidance?
Thanks.
Speaker 2
Right. Yes. So thanks, David. A lot of things have changed really since we made some of those forecasts. We have seen higher costs across the board and things like freight, utilities and logistics, as well as labor.
In addition, As we are looking at the just the overall cost for production, those are going up. So we mentioned that we've, for example, hired now up to 42 aircraft per month on the MAX program. That's in advance of any rate increases to that level. And the reason we did that was to prepare ourselves for higher rates in the future. That means it's a higher investment now.
And so those are the types of pressures and headwinds That make us to conservatively estimate that will be breakeven now including the pension benefit of $120,000,000 to 150,000,000 Mark, anything else to add?
Speaker 4
David, I think Tom summarized it right. We continue to see instability in our factories. We're bringing in much higher headcount to support our 7 37 production. And that is going to have a negative impact on 2023 cost and cash flow. And so that is the first headwind and investment we need to make to drive stability in the factory and meet our delivery commitments to our customer.
Secondly, I had mentioned some challenges in our Kinston facility. We took an additional $60 plus 1,000,000 forward loss. And I had mentioned that, that recovery is going to require us to hire more people, expedite shipments and incur some additional costs to support our customer requirements and indicated that, that cash impact will be $40,000,000 which was not incorporated in our last overall discussion. And then I'll also tell you as we think about the supply chain that we have here, I think it's going to put a little bit of pressure on our working capital. We're needing to bring in additional inventory, provide some buffers ahead of the rate breaks, Probably more so than we anticipated as the stability continues here.
So at this point in time, it's early in the year. We've just started. We want to make sure that we're providing you with some information that we can meet and we'll continue to update you as we progress throughout the year.
Speaker 0
Thank you. Thank you, David. Our next question comes from Kai Van Rommel from Cowen. Kai, your line is now open.
Speaker 7
Yes. Thanks so much. So the pattern of cash flow throughout the year, maybe give us some color there. Is it all 3 quarters of red ink and then 1 quarter of black ink if you're just breakeven. And then related to that, you delivered 33.7% in January.
Is that a sustainable rate or is that just They were sort of pretty much done in the Q4 and because the inventory bulged and now they're just getting out the door. So that's kind of tough to build so that We are not going to get a huge benefit from delivering planes in the Q1. Thank you.
Speaker 2
So Cai, as we said a little bit earlier, cash flow in Q1 is going to be our toughest quarter. And then the cash flow in Qs 2, 3 and 4 should be positive. That's the pattern that we are anticipating. Normally, the Q1 is our hardest because of several one time cash payments that happened, just in the Q1 from a seasonality standpoint. In terms of the production level for January, 33 is a run rate projection.
As we said, we're going to produce about 420 max units for 2023. The plan for Q1 is about 105. So it's just basically right on schedule throughout the year. We do expect some rate breaks in the back half of the year, but the total again is 4 20 units with 105 in Q1 and we started off the year with 33 in January.
Speaker 7
If you mentioned the one timers in the Q1, could you give us some color on what those are because interest basically is gets hit in the 2nd Q4? Thank you.
Speaker 4
Yes, sure, Cai. I mean, the Q1 always is typically from a seasonality standpoint, our worst cash flow. A lot of that has to do with shutting down production At the end of the year. And so what happens is we start out the year, we pay bills, but we go the 1st week or 2 without any cash receipts from all of our customers. And so I would say that is the biggest negative as it relates to our seasonality in the Q1.
Last 7 to 10 days of the year, we don't make any deliveries. And therefore, it takes a couple of weeks for us to start delivering units and starting to get paid. And so cash receipts are always the lowest in the Q1, but you still have 13 payment cycles in the Q1. And therefore, that puts overall pressure on our cash flow. There are some incentive related type, Compensated related things that get paid out in the Q1 that don't repeat.
But you're correct as it relates to The big headwinds on cash as it relates to interest is going to occur in the second and fourth quarters.
Speaker 7
Thank you so
Speaker 0
much. Thank you, Kai. With our next question comes from Sheila Kahyaoglu from Jefferies. Sheila, your line is now open.
Speaker 8
Hi, thank you. So I just wanted to ask Thanks, guys. How are you thinking about the cash burn on the 787, just given the forward losses and what Contribution is in 2023 given the target to deliver between 40 45 ships up. Can you hear me?
Speaker 4
Yes. We can hear you, Sheila.
Speaker 2
Yes. So as we've said yes, 787 is cash burn. 787 right now still continues to burn cash on a per unit basis. Part of it is related to Boeing advance from several years ago that we send with each ship set. So it's about $450,000 per unit.
And then on top of that, As I mentioned, with this new fit and finish, the set of requirements in the bill process is resulting in some more hours, which is creating some further drag in terms of the overall 787 program. We've reflected that in the forward loss that we announced in this quarter. But the 787 does continue to be a challenging program. We do have a price step up at line unit 1405, where we go up to a higher price with Boeing. But until then, the program is going to continue to be negative as we continue to work our cost reduction programs.
Speaker 4
Sheila, I would just add, I think you're going here. If you think about 2020, As Tom said, we're in a forward loss. Everybody understands that our costs are higher than the price and 787 consumes cash.
Speaker 3
So when
Speaker 4
you think about 2022, for most of the year, for a big portion of the year, production was stopped. And so we were incurring costs At the end of the day, you couldn't completely shut down the place. You still had to pay bills and some of the employees. So Our cost per unit at the lower production in 2022 was significantly higher. As we move into 2023, We are going to double production, which will help from a fixed cost standpoint and help reduce our cost per unit.
And so when we think about cash flow, the consumption that we had in 2022 versus 2023, typically as you build more units, That would put more pressure on your cash flow year over year. But with the doubling of production, when we think about the cash consumption in 2022 on 787, How much cash we consumed at delivering 20 units versus how much cash we're going to consume at 45 units. I would say there's a little bit of pressure On cash flow in 2023 compared to 2022. But that's how things shape up. We're going to bring the cost per unit down.
Production starts back up. We're still losing money on it, just a little less than what we lost in 2022, If that helps provide a little bit more clarity.
Speaker 9
Yes. Thank you.
Speaker 0
Thank you, Sheila. Our next question comes from Ken Herbert from RBC. Ken, your line is now open.
Speaker 10
Yes. Hi, good morning.
Speaker 0
Good morning.
Speaker 10
Mark or Tom, I just wanted To see if you could clarify, it sounds like on a per unit basis on the $737,000,000 you talked in the past about breakeven at $31,000,000 a month. Looks like that number is just creeping up with obviously the incremental cost around staffing and supply chain disruptions. Can you level set us Now on how we should think about that for the $737,000,000 maybe sort of where we are today and where you expect it to be at the end of the year?
Speaker 2
Great. Well, Ken, I think it is true that we are seeing higher levels of cost on the 7 37 program right now in particular Because we've overstaffed it to get ready for higher rate breaks. And we've also seen some increases in costs and things like utilities and logistics, and even some labor costs, as well as supply chain. So we said that in the past That once we got to 31 aircraft per month, that would be breakeven. This year, we're going to basically we started the year off at 31 And we're going to continue.
We have a couple of rate breaks later in the year, and we're saying that we're going to be breakeven. So we do have some additional units in this year, But we'll see how everything flows out in terms of how much better we can do. But I would say that We said at 31 aircraft per month, we get back to breakeven. This year, we're going to be consistently at 31 aircraft per month, plus some at the back end of the year, and we will be breakeven. All that said, as I said, there are some higher costs, no doubt about it in the system, which is putting pressure and we're working to offset those.
What will help though is as we continue to go up in rate, we'll absorb more of the fixed cost and we will naturally improve the margin as the rate goes up.
Speaker 4
Yes. Ken, I would just say that the single biggest driver in the difference between being breakeven in the situation we're in now is The instability in the factory. Once we get to stable, we get the out of sequence work built down and behind schedule within the control limits, we'll be right back to our previous expectations of being breakeven at 31. But there's a lot of cost at this point in time and investment that we're making to drive the instability down in the factory to get the factory back Within its control limits. And that's why we're making the investment now here in the Q1 To get that cost down so that we're in a good position to generate positive cash flow going forward and to make sure that we're More than well prepared for the next breaks that happened in the back half of the year.
Speaker 2
So the headcount we're investing in right now is to make us capable of 42, and that's where we expect to end the year. So by having those individuals in place now, they've got their training, they get experience on the job, and we'll be ready for those breaks as they happen.
Speaker 10
Great. Thank you. Just one quick follow-up. Is the instability In the factory, it sounds like it's predominantly rated just related to just the surge in hiring you're having to do to support rate down the road. But are you still seeing Issues with supplier disruption and delays?
Or is it predominantly just labor and the ramp up and training associated with that?
Speaker 2
No, it's both Ken. Certainly, bringing all the new labor on and getting them trained is a factor and we have seen higher levels of attrition. And it just it takes time for people to get up to the levels of productivity that we were at back in 2018 2019. They're getting there. It's just taking some time.
But there's no doubt that there's also still supply chain disruption. We're seeing shortages probably 2 or 3 times higher than when the factory is in steady state. And when you have those kind of supply chain shortages, It creates traveled work. It creates disruption in the factory. It exacerbates all the other issues.
So it really is both things. It's the labor, but it's also the Supply chain shortages. I would say though that the supply chain situation is under better control than we were last year. There are still challenges, but it's definitely improving. We can see that, but we just got to stay laser focused on it.
Speaker 10
Great. Thanks, Tom. Thanks, Mark.
Speaker 4
Thanks, Ken.
Speaker 0
Thank you, Ken. Our next question is from Steve Feldman from JPMorgan.
Speaker 11
Hey, thanks very much. Good morning, everyone.
Speaker 2
Good morning, Seth.
Speaker 11
Tom, I was wondering if you could talk a little bit about the guidance for 737 this year, the deliveries. In the past, there have been plans for rate breaks later in the year that haven't really materialized. And that's left you guys in a tougher position in terms of kind of what you've told the investor community. So can you talk a little bit about your level of confidence in the rate breaks for later this year versus in the past?
Speaker 2
Right. Well, you're right. The schedules have been more volatile over the past couple of years. But We've worked very closely with our customer Boeing in this case to establish what the production rates are going to be for 2023. And they've been very Firm and committed to saying that that's what they will take from us.
And by now, their own production rates may vary, but we know Fairly well at this point that we'll deliver in the 4 20 units and that Boeing is committed to take those. And that's going to involve 2 rate breaks later in the year to achieve it. But we're staffing for it now so that we can make it. So I would say there has been more volatility, But we're further along in the process and post pandemic. And we do expect with a fairly high degree of certainty at this point That's the projections that we have right now for the 4 20 units is what we'll deliver this year.
Speaker 11
Great. Thanks very much.
Speaker 0
Thank you, Seth. Our next question comes from George Shapiro from Shapiro Research. George, your line is now open.
Speaker 12
Yes, good morning.
Speaker 4
Good morning.
Speaker 12
Inventory was up $80,000,000 in the 4th quarter from 3rd. Is that all pretty much due to the 19 3.7 deliveries that were missed?
Speaker 4
George, as always, You're very you're intuitive as it relates to the numbers. You know our numbers very well. I would say for the most part, We had expected to make those deliveries and burn that inventory down. We brought the parts in to support 300 shipsets on the 737. A lot of them are pretty well down the road by the end of the year, but we just with the disruption and some shortages, We just couldn't push those out the door.
So the biggest driver to that growth in inventory between the 3rd Q4 was due to the fact that We didn't make those additional 20 deliveries by the end of the year.
Speaker 12
Okay. And a follow-up, Mark. Given the negative cum catches on the 320 and the 737, How much does that start to impact what you've said in the past that at 42% rate, you'd be able to get back to the 16% margins that you made in 2018?
Speaker 4
I would say this George, and we've talked about it The last couple of calls and then some of the earnings or some of the conferences that we've gone The 16.5% was a good proxy back in 2016. But I would tell you today in 2023, When you think about the macroeconomic environment, when you think about the inflationary pressures overall from a cost standpoint, We're going to have to evaluate that. At this point in time, I think that all of those things that I just talked about are going to put pressure on our ability to achieve the 16.5% margin. We're not backing off our goals to improve our segment margins and get back to the types of cash flow that you saw in 2019 2018. But there are a lot of things that are outside of our control at this point in time that are putting pressure on overall margins.
We know that our pricing is fixed with our customer. And so the way we have to drive those margins is to manage our cost and take advantage of the higher production rates in front of us. But we'll continue to as we move throughout the year, we tackle these higher production rates. First things first, we've got to get our factory stable. We've got to get ourselves to cash flow positive.
And that's what we're really focused on here in 2023 And then improving on that as we move into 2024. And we'll dialogue with you guys every call on our progress to those plans. But At this point in time, there's a lot that has taken place between when we had those conversations and now. But our goals are continue to stretch ourselves to improve our overall profitability and make sure that we're providing great value to our investors.
Speaker 12
Okay. Thanks very much, Mark.
Speaker 0
Thank you, George. With our next question comes from Kristine Liwag from Morgan Stanley. Kristine, your line is now open.
Speaker 9
Hey guys, good morning. On the 4/20 737 MAX production this year, can you guys talk about How you think about the inventory burn down that Boeing already has? Is that factored in? So could we see True production rate and Vinyl Assembly be higher than the $420,000,000 for the year that you have?
Speaker 2
Right. Well, we have taken into account the inventory and the buffers. The $420,000,000 is what we will produce and deliver to Boeing and get paid for. Now we still have roughly 90 units or so in buffer in Wichita. Those will continue to get burned down over time.
But in the meantime, they also provide a cushion to the production system as rates go up. And Honestly, it's quite a useful thing to have that buffer in place. Over the next 2 years, that buffer will get smaller at different times as Boeing's production rate exceeds spirits. But for right now that buffer is in place and it's serving a very purpose to cushion the production system.
Speaker 4
And Christine, I would just add for clarity on what we're focused on is the $420,000,000 it's about 20 units that we didn't deliver in 2022 will carry over. And so we're planning on new production of 400 units. And that's what we expect to put and ship in place and to be paid for. What Boeing delivers to their customers is We have no purview. That's on the Boeing side.
We're just trying to communicate to you what contract schedules we have And what we expect to produce internally and what we expect to ship to Boeing and to get paid for. And so again, I think you have to separate our production from what Boeing delivers because they have a production line, they have stored units. And we can't really opine on what Boeing is going to deliver to their customers. What we do know is we have Contractual commitments to deliver to our customer and that's what our production rates are getting. Yes.
Speaker 2
And just to clarify, the production for the year is going to be 4 20 units, which includes 20 That carried over from last year. So total units production this year and deliveries to Boeing is 420.
Speaker 9
Thanks, guys. If I could do a follow-up question on margins. So I mean before it was $31 per month at breakeven. Now with your guide for $4.20 per year, if we just average that, that's $35 per month for breakeven. I mean, when we get out to 42, How should we think about the margin progression?
And also for when you get to the mid-40s, I mean, it sounded like you guys are walking back the 8.5 percent segment margin. So can you give us an idea of the magnitude of change and where margins could be when you get to that mid-40s rate and stable there?
Speaker 2
Yes. Well, what I would say is as production rates increase, margins will improve. We've certainly seen a lot of headwinds in terms of labor costs, inflation in utilities and freight and logistics and other things in terms of supply chain. And as the production rates increase, the margins will improve. Now at this point, There's been so much change in volatility is we're not making projections in terms of where we'll be at specific times, But they will certainly improve as the production rates increase.
Speaker 9
Great. Thank you, guys.
Speaker 4
Thanks. Thanks.
Speaker 0
Thank you, Christine. With our next question comes from Myles Walton from Wolfe Research. Myles, your line is now open.
Speaker 13
Hey, good morning. You have Lou Raffetto on for Myles. Just a couple of quick cleanups here. Can you guys size the inventory charge in aftermarket in the 4th quarter?
Speaker 2
I'm sorry, could you repeat that?
Speaker 13
Sorry, can you size the inventory charge in the 4th quarter and aftermarket?
Speaker 4
Inventory charges. Sure. It was small. It was we had some excess and obsolete inventory that we had to dispose of in the Q4. It was a couple of $1,000,000 $2,000,000 $3,000,000 If you think about aftermarket, it's $360,000,000 of revenue.
We did about $73,000,000 in the 4th quarter. So $2,000,000 or $3,000,000 could have a pretty big impact on the overall profitability. That probably, Excluding that inventory reduction or charge that we took, aftermarket margins would have been in excess of 20%.
Speaker 13
All right, great. Thank you, Mark. And then just you mentioned there's going to be a pension charge in the Q1. Any way to size that as well?
Speaker 4
At this point in time, we're finalizing that with our actuaries. We're probably thinking somewhere between $70,000,000 $100,000,000 but we're working through the final impacts of that. Again, That is the non cash component of it. And then, we'll also have some tax and excise that we'll have to deal with as part of that closure.
Speaker 6
Okay, great.
Speaker 13
And then just last one, I guess, with all the talk about the cash impact and the margins Going forward, I believe you guys have I'm agreement that expires in June. How, if at all, are you taking that into account for the guidance for this year and just how do we think about that going forward given potential cost increases on that?
Speaker 2
Right. Well, our IAM agreement does expire in June, on June 23. And we have taken into account Any potential impact in our projections that we provided today. So we naturally have seen several other agreements that the IAM has included with Boeing in St. Louis, with Lockheed, with Pratt Whitney, ULA and so forth.
So we've taken into account That potential impact in our projections today.
Speaker 6
Thank you.
Speaker 0
Thank you. Our next question comes from Michael Ciarmoli from Tuohy Securities. Michael, your line is now open.
Speaker 6
Hey, good morning guys. Thanks for taking the question. So I guess just thinking about this production versus deliveries, it sounds like at 400, the implied rate is 33, but I thought you said there were going to be potentially 2 Slide rates 33, but I thought you said there were going to be potentially 2 rate breaks. It doesn't really imply too much of a Step function increase in production, I mean is that how we should look at that or are you guys anticipating higher Monthly production rates in the second half of the year.
Speaker 2
Well, the production rates will go up in the second half of the year. So we'll have a break to 38 and then we'll have a break to 42. And we've taken that into account in the terms of the total number that we're going to produce this year is 420. But that's how we'll have a production rate break. We'll go to 38 in August and 42 in October.
That's the plan. And when you add it out and I think it's important always to focus not on the rates, but on the total numbers of deliveries. The rate break is what you're cycling at any given point. But what really matters obviously is the total number of deliveries in a period.
Speaker 4
Michael, I would just add that the second rate break Happens very late in the year. And so there is some investment in capital working capital that we'll have, But that rate break has very little impact on deliveries. The benefit of deliveries will really mostly take effect in 2024.
Speaker 6
Got it. That makes sense. And then just another one, I mean, do you guys have any opportunities to renegotiate these contracts? I mean, we keep hearing most of the Suppliers out there passing through costs, getting price increases. I mean you guys seem to be structurally stuck here as a price taker.
I mean you mentioned the 787 7 pricing at line unit, 1405. I mean is there anything on the 37 with new blocks So are you just here for the long haul with these prices or with these contracts?
Speaker 2
Well, we're always in discussions with our customers about The current market environment and the pressures that we're facing. The 7 37 contract, the pricing on that is set all the way out to 2,033 And it's indexed to rate as we've said in the past. But on all the programs, we're always in constant discussions with all of our customers in terms of the current market conditions.
Speaker 6
Okay. Got it. Thanks a lot guys.
Speaker 0
Thank you, Michael. Our next question comes from Noah Poponak from Goldman Sachs. Noah, your line is now open.
Speaker 14
Hey, good morning, everybody.
Speaker 5
Good morning.
Speaker 14
Just going to stay on that MAX discussion. Just want to confirm what you're saying is there are rate breaks going on in the system on the MAX to that 38 and that 42. But 1, because you're doing them late in the year and then 2, you kind of get your system there, you break there before you're actually Sustainably delivering there that those don't really generate a significant amount of units for you this year. Is that Correct.
Speaker 4
In particular, the $42 a month that happens way late in the year. That is correct.
Speaker 14
Okay. But should we then think about 2024 shipments as running off of that underlying 42 rate?
Speaker 2
Yes. We'll end the year at 42 and we'd expect to continue at that rate throughout 2024.
Speaker 14
Okay. And I mean, I know there's always a little bit of interesting or difficult, I don't know the right word, but A dynamic of you don't want to get ahead of Boeing, but you physically produce ahead of Boeing. And Boeing wants to be conservative Cautious and everybody is still trying to figure out the health of the supply chain. But I guess I'll just ask it anyway. I mean, how do I foot What you're saying there on MAX rate breaks and when they occur compared to the latest from Boeing is sort of there's still a scenario that They're at 31 a month through this entire year.
And if supply chain is a little better, maybe they can break into the high 30s sometime in the back half of the year.
Speaker 2
Right. Well, what we've given you is the production schedule that we have from our customer. What they determine is their production rate and how they communicate. You'll have to talk But what we've wanted to do here is give you what we have. I mean these schedules have to be put in place for us long in advance.
And that's the schedule that we have right now is to produce 4 20 units and to have 2 rate breaks in the back half of the year. So we just wanted to give you clarity and transparency into what our production schedule is.
Speaker 4
Well, no, I would also think of it this way. Boeing has said by 2020 in 2025, they're going to go to 52 aircrafts per month. So that's we're getting close to 18 months away from that timeframe. So at some point in time, in order to hit 52 aircraft per month, there's going to have to be rate breaks. And all of that can't happen in 2024.
So again, I think again, what Boeing is saying, they're delivering to their customers. That's what they do. We're focused on What do we have to do to meet our contractual commitments to deliver to Boeing? And what they pull from us is their decision at this point in time. But again, Tom talked about 2 rate breaks.
1 of them will help us get to the 4.20 deliveries this year. The other one will bring people in and working capital, but the real benefit from a delivery standpoint really doesn't take place in 2024.
Speaker 14
Okay. And maybe just one more on the topic. Is supply chain actually better? Are the bottlenecks Coming to you, coming to Boeing saying, hey, we're now ready to go. Or is it you and Boeing and those that aren't bottlenecks are saying, Let's just start gunning for it and that will help pull the bottlenecks along.
Speaker 2
No, the supply chain is better. The way I would measure it is just shortages, part shortages. And our shortages are Still elevated, as I said, 2 or 3 times higher than what they would be at steady state, but they're less than half of what they were in at some points in 2022. So we've definitely seen improvement in the supply chain. Now that said, there's always about a dozen suppliers that are in deep distress that we're having to work with.
And often, by the way, we're working closely with Boeing on those suppliers. We actually have right now about 70 people out in the field, Spirit people as well as contractors, working with individual suppliers on the rate deliveries. And in addition to that, We are working on bringing some work in. We have our fab unit, which can help cover. And we also move work to other suppliers that have capacity to level load the system.
But the shortages are still higher than they should be, but they're less than half of what they were. And so that's why I can say there's been some improvement in the supply
Speaker 14
Appreciate all the detail. Thank you.
Speaker 0
Thank you, Due to time constraint, we have our last question from Peter Arment from Baird. Peter, your line is now open.
Speaker 15
Thanks so much. Hey, Tom, just quickly just on the rate breaks, going to 38% and then eventually 42%. Historically, we've always kind of understood that kind of they're done a little more methodically kind of at least 6 month increments. It seems like August October pretty close. Just maybe if you want to highlight how you're thinking about that or whether I'm wrong in my assumption on those rate break increments?
Speaker 2
No, you're right. It's closer than we yes, yes. Thanks, Peter. It is closer than we would normally do, but that's why we've made the investment Now in getting up to the 42 headcount, so that we can practice cycling there essentially all year that will help us do the 38 break in August and then to go to 42 in October. So it's a little closer, but because we have the 42 heads now, which is well in advance of when we would normally have them, We were confident that we could do that and we discussed it in a lot of detail with Boeing and we both agreed that that was the right plan.
Speaker 15
Appreciate the color. Thanks, Tom.
Speaker 0
Thank you. Thank you. We have no further questions on the line. Ladies and gentlemen, this concludes today's call. Thank you for joining.
You may now disconnect your