Westlake - Earnings Call - Q3 2016
November 8, 2016
Transcript
Speaker 0
Good morning, ladies and gentlemen. Thank you for standing by. Welcome to the Westlake Chemical Corporation Third Quarter twenty sixteen Earnings Conference Call. During the presentation, all participants will be in a listen only mode. After the speakers' remarks, you will be invited to participate in a question and answer session.
As a reminder, ladies and gentlemen, this conference is being recorded today, 11/08/2016. I would now like to turn the conference over to your host, Ben Ederrington, Westlake's Vice President and Chief Administrative Officer. Please begin, sir.
Speaker 1
Thank you. Good morning, everyone, and welcome to the Westlake Chemical Corporation third quarter twenty sixteen conference call. I'm joined today by Albert Chao, our President and CEO Steve Fender, our Senior Vice President and Chief Financial Officer and other members of our management team. The conference call agenda will begin with Albert, who will open with a few comments regarding Westlake's performance in the third quarter of twenty sixteen, followed by a current perspective on the industry. Steve will then provide a more detailed look at our financial and operating results.
Finally, Albert will add a few concluding comments, and we will open the call up
Speaker 2
to
Speaker 1
questions. During this call, we refer to ourselves as Westlake Chemical. Any reference to Westlake Partners is to the master limited partnership, Westlake Chemical Partners LP, and references to OpCo refer to our subsidiary, Westlake Chemical OpCo LP, who owns certain olefins facilities. Today, management is going to discuss certain topics that will contain forward looking information that is based on management's beliefs as well as assumptions made by and information currently available to management. These forward looking statements suggest predictions or expectations and thus are subject to risks or uncertainties.
Actual results could differ materially based upon many factors, including the cyclical nature of the chemical industry availability, cost and volatility of raw materials, energy and utilities governmental regulatory actions and political unrest global economic conditions industry operating rates the supplydemand balance for Westlake's products, competitive products and pricing pressures, access to capital markets, technological developments and other risk factors discussed in our SEC filings. This morning, Westlake issued a press release with details of our third quarter twenty sixteen results, along with the schedule of transaction related and nonrecurring items that we will be discussing in more detail. These documents are available in the Press Release section of our webpage at westlake.com. A replay of today's call will be available beginning two hours after completion of this call until 11:59PM Eastern Time on November 1536. The replay may be accessed by dialing the following numbers.
Domestic callers should dial +1 (855) 859-2056. International callers may access the replay at (404) 537-3406. The access code for both numbers is 9000006221252. Please note that information reported on this call speaks only as of today, 11/08/2016, and therefore, you are advised that time sensitive information may no longer be accurate as of the time of any replay. I would finally advise you that this conference call is being broadcast live through an Internet webcast system that can be accessed on our webpage at westlake.com.
Now I'd like to turn the call over to Albert Chao. Albert?
Speaker 2
Thank you, Ben. Good morning, ladies and gentlemen, and thank you for joining us on our earnings call to discuss our third quarter twenty sixteen results. In this morning's press release, we reported quarterly net income of $56,000,000 or $0.51 per diluted share on net sales of $1,300,000,000 We are pleased to have closed our strategic acquisition of Axial during the quarter, which marks a significant milestone for our company this year, which we celebrate our thirtieth anniversary of operations. We welcome many talented colleagues from Axial into the Westlake family with the completion of the acquisition on August 31. We're now more than two months into the integration of our businesses and I'm pleased to see that we are collaboratively working together to identify process improvement and cost saving opportunities in all areas of the combined company.
As a result of the acquisition, Westlake is now the third largest PVC producer and third largest chlor alkali producer in the world. We remain the world's largest specialty PVC producer and the largest LDP producer in North America. We believe this positions us well to meet increasing global consumer demand for these products. Our third quarter earnings reflect a number of transaction related expenses and non recurring events, many of which are related to activities pertaining to our acquisition of Axcel. Posted on our website this morning is a schedule of these expenses and non recurring items, which Steve will touch upon in more detail.
If you look beyond these one time items, you will see that underlying fundamentals for Olefins and Vinyls segments show continued strength since the beginning of the year, following the decline in global crude oil prices, which are lower by approximately 9% in the third quarter from levels seen in the same period last year. As global crude oil prices have recovered from the recent lows levels seen earlier in the year, the global pricing for our major products have also risen. During the quarter, we continue to benefit from good demand for olefins and vinyls products that have benefited from improving consumer spending and also from increasing construction activity. Now I'd like to turn the call over to Steve to provide more detail on the financial and operating results for the quarter. Steve?
Speaker 3
Thank you, Albert, and good morning, everyone. I will start with discussing our consolidated financial results followed by a detailed review of our Olefins and Vinyls segment results. Let me begin with our consolidated results. This morning, Westlake reported net income for the third quarter of twenty sixteen of $66,000,000 or $0.51 per diluted share on net sales of $1,300,000,000 for the quarter ended September 3036. As Albert mentioned, our third quarter results were impacted by a number of onetime items related to the Axial acquisition and planned turnarounds and unplanned outages.
Referring to the schedule we posted on our website this morning, the impact of these events that occurred in the third quarter totaled approximately $54,000,000 after tax or $0.41 per share. Let me briefly explain these items. The first category of expenses is related to the Axial acquisition. Earnings for the quarter were impacted by transaction and integration related costs of approximately $83,000,000 financing associated costs for the acquisition totaling 14,000,000 and $16,000,000 related to the purchase accounting adjustment required to mark up the acquired Axial inventory to market value. Second, our results reflect the nontaxable benefit we received on the Axial shares we purchased prior to the acquisition, which we recorded as income of $49,000,000 Third, as I noted in our prior quarter earnings call, our third quarter results also reflected unabsorbed costs associated with the planned Petro one turnaround and expansion, the unplanned outage in Calvert City and other planned turnarounds totaling approximately $36,000,000 These planned turnarounds and unplanned outages also result in lost sales of approximately $21,000,000 bringing the combined impact to $57,000,000 Fourth, we recorded other nonrecurring charges in the Vinyls segment of approximately $6,000,000 And finally, in addition to the non recognition of tax on the gain of the Axial shares that we previously owned, we benefited from an $11,000,000 in various tax adjustments.
Therefore, if we looked at our quarter excluding these items, our earnings would have been $0.40 higher or $0.92 per share. Net sales for the third quarter of twenty sixteen were $1,300,000,000 higher compared to the third quarter of twenty fifteen, mainly due to sales contributed by Axial in September, partially offset by lower sales prices and volumes for most of our major products. Income from operations of $47,000,000 for the third quarter of twenty sixteen were lower than in the third quarter of twenty fifteen resulting from lower sales prices for most of our major olefins products, transaction integrator related expenses and the effect of selling higher cost Axial inventory recorded at market value. Income from operations in the third quarter of twenty sixteen were also impacted by lost sales, lower production rates and unabsorbed costs associated with the planned Petra One turnaround and expansion and other unplanned and planned outages. Sales revenue in the third quarter of twenty sixteen of $1,300,000,000 increased compared to the second quarter of twenty sixteen, while income from operations of $47,000,000 was lower.
The net increase in net sales was largely due to one month of sales contributed by Axial in September and higher sales price for most of our major products, partially offset by lower sales volumes. Lower operating income was a result of the transaction and integrated related costs associated with the acquisition that I previously mentioned and the effect of selling higher cost Axial inventory recorded at market value. Third quarter results were also affected by lower integrated olefins margins that were due to higher feedstock and inventory cost and a $19,000,000 swing in trading activity in the third quarter of twenty sixteen as compared to the second quarter of twenty sixteen. For the nine months ended September 3036, net income was $300,000,000 or $2.29 per diluted share on net sales of $3,300,000,000 both of which were lower compared to the nine months ended September 3035. Net income for the nine months ended September 3036 was impacted by pretax and integration related cost of approximately $91,000,000 associated with the acquisition, financing and associated cost for the acquisition totaling $15,000,000 and $16,000,000 related to the purchase accounting adjustment that I mentioned.
The results also reflected the pretax unabsorbed costs associated with the Petro one turnaround and expansion, unplanned outages and other planned turnarounds totaling approximately $116,000,000 and lost sales associated with these planned turnarounds and unplanned outages of $23,000,000 This decrease was partially offset by realized gain of approximately $49,000,000 and a lower effective tax rate that was a result of onetime items totaling $29,000,000 Net sales for the nine months ended September 3036 were lower than reported in the prior year period as a result of lower sales prices for all major products and lower sales volumes for ethylene, polyethylene, ethylene co products, partially offset by higher sales volumes for PVC resin and sales contributed by Axial and Wazu, our Chinese joint PVC joint venture. Income from operations was $429,000,000 for the nine months ended September 3036, a decrease from the prior year period resulting from lower sales prices for all of our major products, transaction and integration related costs and lost sales, lower production rates and unabsorbed costs associated with the planned turnarounds and unplanned outages I previously mentioned. These decreases were partially offset by lower average feedstock and energy costs and higher production margins higher product margins in our European operations.
Our utilization of the FIFO method of accounting resulted in an unfavorable impact of $19,000,000 pretax or $0.10 per share in the third quarter compared to what earnings would have been reported on the LIFO method. This calculation is only an estimate and has not been audited. Before we move on to review the performance of our two segments, I'd like to point out that following the acquisition, the assets acquired, liabilities assumed and the results of operations of the Axial business are now included in our Vinyls segment. Now let's start by discussing our Olefins segment. In the third quarter of twenty sixteen, Olefins segment reported income from operations of $118,000,000 on net sales of $497,000,000 These results were impacted by lost sales, lower production rates and unabsorbed costs related to the Petro one ethylene unit turnaround and expansion as well as other planned turnarounds during the quarter.
Third quarter twenty sixteen net sales were lower than in the third quarter of twenty fifteen, also due to lower sales prices. Compared to the second quarter, third quarter results saw a decrease of $22,000,000 in operating income, while sales increased by $3,000,000 The decline in operating income was partially due to lower integrated olefins margins, primarily due to higher feedstock and inventory cost. Additionally, trading activity in the third quarter of twenty sixteen resulted in a 7,800,000 loss compared to a gain of $11,500,000 in the second quarter of twenty sixteen. These decreases were partially offset by higher production rates and lower unabsorbed costs related to Petro one turnaround and expansion as compared to the prior period. For the nine months ending September 3036, Olefins segment reported income from operations of $4.00 $8,000,000 which was lower than income from operations reported for the nine months ended September 3035, mainly due to reduced integrated olefins margins resulting from lower sales prices and the impact from the planned and unplanned outages.
Now moving on to the Vinyls segment. The Vinyls segment reported income from operations of $22,000,000 in the third quarter of twenty sixteen on net sales of $782,000,000 Our Vinyls segment third quarter operating income decreased from the same period last year as they were impacted by lost sales, lower production, unabsorbed costs associated with the unplanned outages at the Calvert City facility and other planned maintenance turnarounds that took place at our European facilities in the quarter. As a result of purchase accounting, we marked up the inventory that we acquired from Axial to market value. And the third quarter results were negatively impacted by the effect of selling the higher cost Axial inventory that was previously reported at cost. The net sales for the third quarter of twenty sixteen benefited from the one month of sales contributed by Axial in September.
When compared to the second quarter of twenty sixteen, operating income was lower as a result of selling higher cost Axial inventory at market value and also lower building products margins partially offset by higher caustic sales prices. Operating income for the Vinyls segment for the nine months ended September 3036 was $137,000,000 which was lower compared to the nine months ended September 3035. The decrease in operating income was a result of planned turnarounds and unplanned outages that I previously described and also the result of lower sales prices for our major products, partially offset by higher product margins in our European operations as compared to the first nine months of twenty fifteen. Now let's turn our attention to our balance sheet and cash flow. For the first nine months of twenty sixteen, cash generated from operating activities was $544,000,000 and we invested $467,000,000 in capital expenditures.
At the end of third quarter, we had cash of approximately $381,000,000 and long term debt was approximately $3,700,000,000 We will focus on prudently managing our balance sheet and maintaining investment grade ratings. Now allow me to provide some guidance following our acquisition for modeling purposes for the remainder of 2016 and into 2017. Our estimate for 2016 capital expenditures including Axial's capital expenditures from August 31 onward is expected to be in the range of 600,000,000 to $650,000,000 Our 2016 capital forecast includes spending for the acquisition of our Petro one ethylene unit, which we completed in July and our investment in the Lotte ethylene joint venture, which is located adjacent to our Lake Charles complex. It also includes early engineering work and the purchase of long lead items related to the expansion of our Calvert City ethylene unit that we announced in January. We expect to see transaction and integration related expenditures of approximately 5,000,000 to $10,000,000 in the fourth quarter related to the Axcel acquisition.
And we estimate that our 2016 effective annual tax rate for the year will be approximately 31% and our cash tax rate will be approximately 10%. We also have a major turnaround at our Lake Charles Vinyls facility planned in the fourth quarter that will impact earnings by approximately $30,000,000 Looking forward into 2017, we are evaluating our capital expenditure budget for next year and we will discuss this when we announce our full year 2016 results. We have scheduled our Calvert City ethylene unit turnaround and expansion for the first quarter of twenty seventeen and we expect unit to be down for approximately three weeks. We're also planning for major turnarounds in our Plaquemines chlor alkali unit in the first quarter lasting approximately twenty four days. Our annual interest expense is expected to be approximately $160,000,000 and our annual depreciation and amortization will be approximately $545,000,000 As we continue to integrate our newly acquired business, we are focusing on capturing synergies and the $100,000,000 cost savings initiatives that Axial previously announced.
We believe we will be able to capture approximately $100,000,000 in annual synergies within the next two years. For 2017, we anticipate we'll be able to capture approximately $70,000,000 in synergies while spending $20,000,000 to achieve these synergies. With that, I will now turn the call back over to Albert to make some closing comments. Albert?
Speaker 2
Thank you, Steve. Overall, our third quarter results were good. Although the results were impacted by several items related to the acquisition and the other one time events, including planned and unplanned outages. We saw improving fundamentals from the beginning of the year as we benefited from higher integrated product prices and margins and good demand for olefins and vinyl products. We continue to see improving future demand growth for our chlor alkali and PVC products with consumer demand forecast to increase over the next several years as construction spending in global economies continue to recover.
As a global leader in the chlor alkali and vinyls market, we believe that we are well positioned to benefit from this recovery and to continue to benefit from our low cost position compared to the rest of the world. As we integrate Axial into Westlake, remain focused on efforts to align our business operations and to identify areas of best practice and cost reduction. We're working towards implementing synergy opportunities that will improve the financial performance of the combined organizations that make up the new Westlake. To date, we have identified $100,000,000 in annual run rate synergies that we expect to be able to achieve within the next two years. We will continue to look for even more value.
We are currently evaluating opportunities to improve the operational and financial performances of these acquired assets, which will require incremental investments in the maintenance and reliability of our operations, which we believe will lead to bottom line improvement in the financial performance of our business in the future. We're very pleased with efforts over the last two months to drive the value of putting these two businesses together. We look forward to reporting our future results. Thank you very much for listening to our earnings call this morning. Now I'll turn the call back over to Ben.
Ben?
Speaker 1
Thank you, Albert. Before we begin taking questions, I would like to remind you that a replay of this teleconference will be available starting two hours after we concluded the call. We will provide that number again at the end of the call. Christy, we are now prepared to take questions.
Speaker 0
Thank you. Our first question is from the line of Jim Sheehan of SunTrust Robinson. Your line is open.
Speaker 4
Good morning. Thanks for taking my question.
Speaker 2
Good morning.
Speaker 4
So when you think about the synergy opportunity that you've got with Axial, you're talking about $100,000,000 run rate over two years. And as you've had opportunity to look at the Axial operations this past quarter, do you see any scope for upside there? And could you also talk about could you try to quantify what type of investment you might make in Axial's facilities in order to upgrade them?
Speaker 3
Jim, good question. As I mentioned in my prepared remarks, we've already started our work to achieve these synergies that I noted. We've spent about $20,000,000 that we expect and achieve $70,000,000 of synergy. And I expect that number to continue to improve toward that $100,000,000 target that you mentioned. And as Albert noted, we will also look for additional value in synergies.
As you can imagine, we won't just stop at the $100,000,000 number. As it relates to future expenditures, we're assessing those today. Certainly as we do our as we work through our 2017 capital budgeting plan, We'll be looking for those kind of opportunities and be able to speak more clearly to those after we've approved the 2017 budget. And we'll talk about that when we get to our fourth quarter results in February. I don't have a number for you today.
Speaker 4
Great. And in terms of your Building Products business, you talked about a little margin pressure there. Could you talk about what is causing that margin pressure and what's your outlook for Building Products margins going forward?
Speaker 2
Certainly, as you know we have increased our PVC price by $02 a pound in October and we're heading into the winter season where demand typically are lower for building products and we have to pass through the past increase, our PVC revenue increase. But as you know that as you may know, the export price of PVC has improved a great deal especially in Asia. So we see a reasonable chance for the price increase to improve as well as for the building products.
Speaker 4
Great. And last question if I may. Could you talk about the expansions of capacity in polyethylene? I think most of them are in different grades than you're directly exposed to. But how do you see your relative position in the industry as those expansions unfold?
Speaker 2
Certainly, takes one pound of ethylene to make up one pound of polyethylene and with the ethylene expansions, fair amount of polyethylene capacity is being added in The US. And primarily the new capacity are in high density and near low, some in ODPE. And as well as these are very large plants, we anticipate that these plants will focus more on the large volume commodity grades and for Westlake 60% of our polyethylene is LDPE and which has a higher margin than typical linear lower density. And we also 80% of LDPE autoclaves. So the autoclaves tend to have a higher margin because of the specialty products they make than the tubular LDPE.
So we'll be focusing more on the specialty area of the polyethylene business.
Speaker 4
Thank you very much.
Speaker 2
You're welcome.
Speaker 0
Thank you. Our next question is from the line of Don Carson of Susquehanna. Your line is open.
Speaker 5
Yes, thank you. Just wondering whether you scaled back the axial facilities on the VCM side in September, whether you're planning to do so in Q4 given the squeeze from running those units on purchased ethylene? And can you also talk about your caustic realizations, how much they were up in the quarter and what your typical lag is in terms of achieving caustic price increases?
Speaker 2
Certainly. According to what's reported IHS there's probably $40 a pound a short term of caustic price that was effective in the third quarter of twenty sixteen. And as some of our pricing some monthly some are quarterly and as the terms of the contract allows we will be getting these price increases. And can you comment on
Speaker 5
your VCM operations, how you're running those? And then as you look out over the next few years to the extent you're not able to get cost of service ethylene, will you be continuing to run those at reduced rates?
Speaker 2
Well actually ethylene price as we speak has come down from the high we've seen in third quarter and today's the $0.24 a pound or so, it's quite competitive. It's much lower than ethylene prices in Europe and Asia. So I think US would be well positioned to have a low cost position to supply DCM in The US or overseas.
Speaker 5
And then final question, as you've reviewed the Axial assets and integrate them into Westlake, are there any potential capacity rationalizations you would see particularly on the chlor alkali side?
Speaker 2
Certainly we will evaluate all our businesses and performances but as of now we do not see any have any plan to curtail capacities for our clockwise assets. Thank
Speaker 6
you. You're welcome.
Speaker 0
Thank you. Our next question is from Kevin McCarthy of Vertical Research Partners. Your line is open.
Speaker 7
Hi this is Matthew on for Kevin.
Speaker 2
Hi, Matthew. Just a quick one
Speaker 7
for you. So in regards to the £1,000,000,000 short ethylene position you have post the completion of the new Alote JV and the option exercise, how quickly will you look to close this shortfall? And how do you balance that out given your natural inclination to be maybe 100% vertically integrated with the expectation that oversupply is kind of common in the ethylene industry over the next few years?
Speaker 2
That's a good question. In the past we have had positions where we're long ethylene or short ethylene and sometimes better be short ethylene than long depending on the market conditions. And certainly we'll be evaluating various opportunities whether to debottleneck further existing ethylene plant or the new joint venture plant. Typically new plants can also be debottlenecked and we'll look at other types of joint venture, potential acquisitions or just plain purchase whether it's on a formula basis or market price basis.
Speaker 7
Okay. And I guess as a follow-up, I mean do you have any comments on your willingness to pursue other M and A opportunities at this juncture, just especially as it relates to my first question given the assets we have on the block?
Speaker 3
Yes. This is Steve. I think the answer is that as we see valued opportunities, we'll certainly look at those very closely. And again, it boils down to what the particulars are of that particular opportunity. But I would say that anything that looks of real value to us where we can find incremental value, we certainly will pursue that with interest.
Speaker 7
Okay. But within the construct of your investment grade credit rating, we shouldn't see you as constrained I guess?
Speaker 3
Well, back to my earlier comments, I think you're going to see us look at keeping that investment grade rating. But as I mentioned earlier, we have a variety of levers that we can work with and still pursue opportunities and still keep that investment grade set of metrics.
Speaker 7
Perfect. Thank you. You're welcome.
Speaker 0
Thank you. Our next question is from Hassan Ahmed of Alembic Global. Your line is open.
Speaker 8
Good morning, Albert and Steve. Morning.
Speaker 9
Guys, the PVC side of things, obviously, you guys talked about some near term pricing momentum building. Just broadly speaking in terms of sort of some of the trends that you are seeing particularly as they relate to the cost curve. Obviously we've seen coal prices rising, carbide and ethylene prices aren't as high as they used to be. So could you just give me a sense of what to expect from a pricing perspective in this new Asian coal price regime that we are seeing? I mean is it supportive of further price hikes, you know, call it to the course of 'sixteen into 'seventeen?
Speaker 2
That's a good question. As we are seeing since the G20 meetings in Shanghai and China recently that the Chinese government and Chinese market has been trending down on high CO2 emission areas such as coal fired power plants. So we are seeing a higher increasing coal prices, a reduction in production of PVC and caustic. I think we'll be benefiting both from higher PVC price in Asia, in China, and possibly in The US as well as higher caustic prices and less imports from Asia to the West Coast Of The US where we have a chlor alkali plant. So we don't know how long the Chinese government would enforce these reducing carbon emissions but if you continue to do so which we hope that will be the case and then our industry and Westlake should benefit from those actions.
Speaker 9
Very good. Now as a follow-up on the Olefins side of things, you know, obviously much debate about the future of NGL pricing, particularly as more and more of this North American ethylene capacity comes online. And, you know, one of the sort of often cited arguments that I hear is that regardless of how tight ethane may get, there's a very natural relief valve on the propane side of things. Right? So a lot of capacity may switch over from ethane to propane.
So my question really is, as I take a look at a lot of the new greenfield capacity that's expected to come online in The U. S, a lot of it seems to be ethane only. So the question is, is there enough sort of capacity out there in The U. S. Market overall for it to be able to switch over to propane if that is the sort of, you know, more attractive feedstock for there to be sort of a reason to consider propane as a relief valve, you know, in that sort of an environment?
Speaker 2
That's a good question also. I think that today US is running about 70% of its ethylene production from ethane and I think propane is about 15% and the rest is butane light daphtha. I think that because of the of the older existing crackers, they have been heavy crackers of naphtha as well as propane. We believe that suddenly they can improve the propane position above 15% maybe to 20% or even higher. If there's a need, smart engineers will find a way to work.
But as of now I think ethane is still preferred feedstock and we expect to continue to be so for several years going forward over propane. Very good.
Speaker 9
Thank you so much guys.
Speaker 2
You're welcome.
Speaker 0
Thank you. And our next question is from the line of Arun Viswanathan of RBC Capital Markets. Your line is open.
Speaker 10
Good morning. Thanks. Good morning. I guess the first question is on the chlor alkali side. I just wanted to understand the earnings sensitivity now.
Would it be proper to assume that now with potentially over 3,000,000 tons of capacity, you know, there's been over $50 or so a ton achieved on the caustic side that you'd see a potential $150,000,000 improvement in EBITDA next year if we were to hold on to all those increases?
Speaker 3
No. I think Arun that's the math is right. And I think the issue is, as we march forward, you've seen I think a better balanced market both in The Americas as well as in Europe where you've seen ourselves and others speak to the regulation that is really bringing more rationalization of mercury based production of chlorine there. And I think what you're seeing really in the Northern Hemisphere as Albert noted and Hassan just a moment ago about what's happening in Asia, a better balanced overall market in the entire Northern Hemisphere, Asia, Europe and The Americas.
Speaker 10
Right. I guess my concern is that, you know, there have been a lot of increases announced and they're reflected in the index but, you know, very little of that is actually being reflected in results. So I'm just trying to understand why that is the case and if you've seen an increase in either discounting or lags on your sales.
Speaker 2
Yeah, I think as I said earlier, some contracts for us are short term monthly, some are quarterly, so something takes a bit longer to achieve. But I think the trend is that other than the announced expansion that's coming up finishing this year, early next year, there's no more new capacity added in The US for chlorine. And the, as Steve mentioned about the reduction in mercury chlor alkali production in Europe end of next year, plus the reduction in Asia and China primarily that we'll see the operating rates for U. S.
Speaker 7
Chlor
Speaker 2
alkali production improve from low mid-80s to high 80% or even 90% over the next several years. And that should help The U. S. Chlor alkali industry going forward. The global demand for caustic is still increasing between half to one time GDP and with the lack of new capacities it should help out The U.
S. Chlor alkali production.
Speaker 10
Okay, thanks. Then on the olefin side, you do have a couple of nominations for price declines over the next couple of months. How do you see the polyethylene pricing shaping up picture shaping up over the next quarter or two especially as some of the, capacity that's been offline earlier in the year restarts and then more capacity is added next year?
Speaker 2
Certainly, as you know that the industry had a $05 a pound price increase in September and stays flat in October and there's industry consultant saying that there potentially could be a reduction in November in polyethylene prices. But if you're looking at the demand domestically, it's quite strong and export demand is quite strong. The pricing export is also good. So we see a very strong global demand for polyethylene and if prices do go down because of the year end inventory adjustments so that we don't see that as a long term basis. Now next year some of the new capacity could be coming on second half of next year which may have impact on prices in The US.
However, also depending on the crude oil prices, if crude oil prices does improve further next year, it will make U. S. Ethane based integrated polyethylene manufacturers much more competitive and may or may not have that impact in The U. S. Market.
Speaker 10
And just a last question if I may. You spoke earlier about, you know, the advantages of being long or short ethylene at different times. I guess what is your preference over the next couple of years? Would you be willing to kind of lock in volumes at cost based prices? Or how do you think you're going to be approaching the ethylene side of your supply?
Certainly.
Speaker 2
Right now until the Lotte joint venture start ups in 2019, Westlake will be buying approximately £1,800,000,000 of ethylene and almost all of that goes into our external vinyls business. So if ethylene is oversupplied in The US without capacity for ethylene exports then ethylene price could stay low which would be beneficial to Westlake and the vinyl industry which purchased a fair amount of ethylene in the merchant market to be more competitive compared to the rest of the world.
Speaker 6
Great, thanks. You're welcome.
Speaker 0
Thank you. Our next question is from Robert Koort of Goldman Sachs. Your line is open.
Speaker 11
Yes, thanks for taking our questions. This is Chris on for Bob. Hi, Chris. Could you give us the impact Axial had on volumes in the final segment and even the EBITDA during the third quarter?
Speaker 3
As it relates to how we're going to be reporting our business, as I mentioned earlier, we're going to have our two segments, the olefins and vinyl segment, and we don't expect that we're breaking out subdivisions of those segments on a go forward basis. So as we go forward, we're not going to be reporting the Axial results or any other acquisition that are embedded in that Vinyls segment. As you can imagine, we only had one month of contribution of Axial. So it was a relatively small contribution in that third quarter.
Speaker 11
Got you. And I guess looking into the next year, what's the maintenance schedule looking like in 'seventeen? And what's your best guess at what the impact might be?
Speaker 3
Well, gave a yes, in my prepared remarks I gave you kind of an outline of what we saw as major planned events as we get into 'seventeen. And as we look at our turnaround schedule we'll call out major turnarounds or major outages as we march forward. But I did mention that we'd have Plaquemine down as I noted for twenty four days in my prepared remarks. But as we get forward into 'seventeen we'll give some guidance on those more than normal run rate of outages for the major events. Obviously given the number of units we have there's always something going through maintenance on a regular basis these days.
Speaker 7
Appreciate it. Thanks for the time.
Speaker 2
You're welcome.
Speaker 0
Thank you. Our next question is from John Roberts of UBS. Your line is open.
Speaker 12
Thank you. Steve, you gave full year amortization and depreciation estimates of $545,000,000 Does that include the full step up from Axial?
Speaker 3
It does, it does.
Speaker 12
And then secondly, I don't know if you want to answer it on this call or later, but where are you with the IRS on WLKP right now?
Speaker 3
Well the answer is we're all waiting for the IRS come out with their final regulations. As I think has been well discussed in the marketplace, Kirk Wilson who's the Associate General Counsel of this service said there'd be something out prior to Labor Day and obviously he did not make that timeline. He since said subsequently that he hopes to this is a comment he made at the MLP Association meeting in DC about a month and a half ago. He said he'd hope to see something issued prior to the end of the year. And I think he's still hoping to be on that track and that's still our expectation.
But we have no other news other than what he's made public in his public comments. And so we hope there is something coming quite soon.
Speaker 13
Okay, thank you. Sure.
Speaker 0
Thank you. Our next question is from Jeffrey Zekauskas of JPMorgan. Your line is open.
Speaker 8
Hi, good morning.
Speaker 3
Good morning, Jeff. Good morning, Jeff.
Speaker 8
You spoke of reducing the Axial costs by $100,000,000 Did you also speak of a separate cost reduction program that Axial had that was also $100,000,000 or is 100,000,000 the number you're shooting for?
Speaker 3
So Jeff, what we referred to are two buckets that are both happened to be $100,000,000 One is the synergy number which is a cost reduction related synergy number that comes from combining the two business. The second is a profit improvement plan that Axial had initiated prior to our acquisition of the company, which is $100,000,000 And certainly, we expect, as I noted, to achieve those savings in 'seventeen while we work toward the synergy number which as we said would be probably a two year run rate to achieve those.
Speaker 8
So you're trying to achieve roughly 170 next year if you combine the two programs?
Speaker 3
That would be right.
Speaker 8
Okay. What's the status of the Eastman Pipeline dispute? Is that all over with or is it still carrying on?
Speaker 3
You know the tariff has been I think resolved and was publicly discussed and we still remain in a court kind of setting really for the directional flow of ethylene in the pipeline.
Speaker 2
Okay.
Speaker 8
When you look at the elevation in Asian PVC prices, what do you attribute it to?
Speaker 2
So about which products?
Speaker 8
You were speaking of PVC prices moving up in Asia and I was wondering why you thought they were moving up.
Speaker 3
Well we've seen certainly as you heard us speak earlier about thermal coal has moved up and what we've seen there is moving kind of a cost structure higher. And certainly as Albert noted earlier, we've also seen a sustained level of both growing demand, global demand. And so I think those two have coupled together to provide both a higher cost structure and a continued growth in demand. I don't know Albert if you want to add.
Speaker 2
We also see a lesser production of carbide based PVC in China hence the demand for imported PVC has increased.
Speaker 8
Okay. Thank you so much.
Speaker 6
You're welcome.
Speaker 0
Thank you. Our next question is from the line of Frank Mitsch of Wells Fargo Securities. Your line is open.
Speaker 14
Good morning gentlemen. Good morning. Good morning. Steve, I wanted to come back with the comment regarding targeting investment grade rating and you said you had multiple levers to pull. How do you how should we think about the goals on reducing the leverage that you have?
Or conversely, how high of an amount for the right property would you be able to spend and still maintain that investment grade rating? How should we think about Westlake's, you know, targeting of that investment grade rating on both, you know, raising it or lowering it?
Speaker 3
Yeah. And so Frank, when you think of investment grade rating, don't think only of leverage per se. Really also think in terms of free cash flow. And so when you think in terms of the various metrics that the agencies, Moody's Fitch and S and P all speak of, obviously leverage is one of those. But there are a variety of other metrics of free
And so as we think about our efforts to keep an investment grade rating, that's certainly our focus to delever and that's a focus that we'll have as we move forward. But obviously should there be opportunities that come forward that look interesting to us, those opportunities bring cash flow associated with them and so some incremental ability to lever that cash flow. And so you needn't only look at the existing cash flows of Westlake but the cash flows of the combined Westlake and whatever opportunity that might be. So you have to look at the additive effect of what that opportunity is and therefore the leveragability of the combined transaction.
Speaker 14
All right. So delevering is the first priority. However, you'd be willing to enter into another transaction and factoring in the cash flows that's going to be coming from whatever unit you acquire to maintain that investment grade rating. And it's tough to define a metric in terms of how large you could stretch to maintain that because I guess you don't know the free cash flow of the properties. Is that basically the answer here?
Speaker 3
Yes. And I think when you look at the Moody's, S and P and Fitch, they all have slightly different criteria in terms of how they define leverage. And so I look to those metrics as really the guidepost rather than us setting a particular measure because those as you know over time have evolved and changed. And so I look to Moody's, S and P and Fitch in terms of their metrics and those are the ones we look toward in terms of achieving and demonstrating to them that we are investment grade today and continue to work toward keeping a strong investment grade set of metrics. But as I say, any opportunity that presents itself likely will bring cash flows and certainly we would add those to ours in terms of what we how we think about the overall leveragability.
Speaker 9
All
Speaker 7
right, great. Thank you.
Speaker 2
You're welcome.
Speaker 0
Thank you. Our next question is from Matthew Blair of Tudor, Pickering, Holt. Your line is open.
Speaker 13
Good morning, Albert and Steve. Good morning, Matthew. Had a question on your JV cracker project with Lotte. Is the 2019 start date and the $1,900,000,000 cost, are those still good assumptions? And then just in general, how excited are you about this project?
Would you expect it at this point to take down the 50% stake? Or would you expect to stay at the 10% stake?
Speaker 3
So as it relates to the project cost, the project is a project that does not have a it's not a lump sum turnkey type structure. And so while we have a commitment at ten percent with a cap on our commitment, as you noted, we do have an option to step our interest from 10% to a higher percent all the way up to 50% of our choosing depending on what we see the capital cost eventually to be. And that option is available to us up to three years post completion of the unit. So up to 2022, I guess, with a completion of 'nineteen. So we'll assess the opportunity set that that creates for us.
And as Albert noted, look and see how we think about ethylene and the price to acquire ethylene over the time period.
Speaker 13
Okay, sounds good. And then for the European chlor alkali market, I think there's some news today that a couple more plants are converting over to membrane before the 2017 deadline. And so now it looks like about half the plants are going to be switching over. Is this all in line with your thinking with what you would have expected a couple of years ago? Is it better?
Is it worse? Has anything changed on caustic for you going forward?
Speaker 2
Yes, I think some analysts are saying it's between 800,000 to 1,000,000 tons of net capacity to be taken out. Time is short because conversion will take some time and it's the end of twenty seventeen people need to shut down the mercury grade chlor alkali.
Speaker 13
Okay thank you very much.
Speaker 6
You're welcome.
Speaker 0
Thank you. Our next question is from Kevin McCarthy of Vertical Research Partners. Your line is open.
Speaker 7
Hi, guys. It's Matt. Just a follow-up or just another question if I could squeeze one in. Was just interested in your, you know, long term strategy for the building products business As it currently stands, just given the size of the business versus the overall company, kind of seem like either use it as a platform for growth or you kind of monetize it. Just wondering what you how you think about it?
Speaker 2
Well, it's a business that's integrated to the vinyls business and the legacy Westlake has a pretty strong building product business and now combined with the Axo legacy building product business that we are one of the major players in The US market. So we will evaluate all the businesses within the building product business and we'll see what the value is worth to Westlake versus the market. I know that Axel went through an exercise trying to sell the business so we are aware of other people's interest and we'll be evaluating as I said the value to Westlake versus other people's valuation. But I think right now we are quite comfortable with the business going forward being an integrated business with our Vinyls business.
Speaker 7
Okay. Thank you, Albert. You're welcome.
Speaker 0
Thank you. And that concludes our Q and A session for today. I'd like to I'll turn the call back over to Mr. Ben Ederrington for any further remarks.
Speaker 1
Great. Thank you. Thank you for participating in today's call. We hope you will join us for our next conference call to discuss our fourth quarter and full year twenty sixteen results. Have a good day.
Speaker 0
Thank you for participating in today's Westlake Chemical Corporation Third Quarter twenty sixteen Earnings Conference Call. As a reminder, this call will be available for replay beginning two hours after the call has ended and may be accessed until 11:59PM Eastern Time on Thursday, 08/04/2016. The replay can be accessed by the following phone numbers. Domestic callers should dial 555056. International callers may be may access the replay by dialing phone number (404) 537-3406.
The access code for both numbers is 900000622152.