Allison Transmission - Q1 2016
April 26, 2016
Transcript
Operator (participant)
Good morning. Welcome to Allison Transmission's first quarter 2016 results conference call. My name is Melissa, and I will be your conference operator today. At this time, all participants are in a listen-only mode. After the prepared remarks, the management team from Allison Transmission will conduct a question-and-answer session. Conference call participants will be given instructions at that time. As a reminder, this conference is being recorded. If anyone should require operator assistance during the conference, please press star zero on your telephone keypad. I would now like to turn the conference over to Fred Bohley, the company's Vice President of Finance. Please go ahead, sir.
Fred Bohley (VP of Finance)
Thank you, Melissa. Good morning, and thank you for joining us on our first quarter 2016 results conference call. With me this morning are Larry Dewey, Allison Transmission's Chairman and Chief Executive Officer, and Dave Graziosi, Allison Transmission's President and Chief Financial Officer. As a reminder, this call, webcast, and presentation we're using this morning are available on the investor relations section of our website, allisontransmission.com. A replay of this call will be available through May 3. As shown on page two of the presentation, many of our remarks today contain forward-looking statements based on current expectations.
These forward-looking statements are subject to known and unknown risks, including those set forth in our first quarter 2016 results press release and our annual report on Form 10-K for the year ended December 31, 2015, and uncertainties and other factors as well as general economic conditions. Should one or more of these risks or uncertainties materialize, or should underlying assumptions or estimates prove incorrect, actual results may vary materially from those that we express today. In addition, as noted on page three of the presentation, some of the remarks today contain non-GAAP financial measures as defined by the SEC. You can find reconciliations of the non-GAAP financial measures to the most comparable GAAP measures attached as an appendix to the presentation and to our first quarter 2016 results press release.
Today's call is set to end at 9:00 A.M. Eastern Time. In order to maximize participation opportunities on the call, we'll take one question from each analyst. Please turn to slide four of the presentation for the call agenda. Now I'll turn the call over to Larry Dewey.
Larry Dewey (Chairman and CEO)
Thank you, Fred. Good morning, and thank you for joining us today. On today's call, I'll provide you with an overview of our first-quarter performance, including net sales by end market. Dave will review the first-quarter financial performance, including Adjusted EBITDA and Adjusted Free Cash Flow. I'll wrap up the prepared comments with the full-year 2016 guidance update prior to Q&A. We're pleased to report that Allison's first-quarter 2016 results are within the full-year guidance range as we provided to the market on February 8. The year-over-year reductions in the global off-highway and service parts, support equipment, and other end markets net sales are consistent with the previously contemplated impact of low energy and commodity prices.
During the first quarter, Allison also continued to demonstrate solid operating margins and free cash flow while executing its prudent approach to capital structure and allocation. Please turn to slide five of the presentation for the Q1 2016 performance summary. Net sales decreased 8% from the same period in 2015, principally driven by lower demand in the global off-highway and service parts, support, equipment, and other end markets. Gross margin for the quarter was 46.5%, a decrease of 100 basis points from a gross margin of 47.5% for the same period in 2015, principally driven by decreased net sales, partially offset by favorable material costs and lower manufacturing expense commensurate with the decreased net sales.
Adjusted net income decreased $41 million from the same period in 2015, principally driven by decreased net sales, stockholder activism expense, dual power inverter module, or DPIM, extended coverage program adjustments, increased cash interest expense, and unfavorable product warranty adjustments, partially offset by favorable material costs and lower manufacturing expense. Please turn to slide six of the presentation for the Q1 2016 sales performance summary. North America on-highway end market net sales were down 4% from the same period in 2015, principally driven by lower demand for Rugged Duty Series models. North America hybrid propulsion systems for transit bus end market net sales were down 6% from the same period in 2015, principally driven by lower demand due to engine emissions improvements and non-hybrid alternatives that generally require a fully automatic transmission.
North America off-highway end market net sales were down 77% from the same period in 2015, principally driven by lower demand from hydraulic fracturing applications. Defense end market net sales were flat with the same period in 2015, principally driven by higher demand for wheeled defense, offset by lower demand for tracked defense. Outside North America, on-highway end market net sales were up 23% from the same period in 2015, principally driven by higher demand in Europe and Japan. Outside North America, off-highway end market net sales were down 81% from the same period in 2015, principally driven by lower demand in the energy and mining sectors.
Service parts, support equipment, and other end market net sales were down 13% from the same period in 2015, principally driven by lower demand for global off-highway service parts, partially offset by higher demand for global on-highway service parts. Now, I'll turn the call over to Dave Graziosi.
Dave Graziosi (President and CFO)
Thank you, Larry. Please turn to slide seven of the presentation for the Q1 2016 financial performance summary. Given Larry's comments, I'll focus on other income statement line items and Adjusted EBITDA. Selling, general, and administrative expenses increased $6 million, after excluding the stockholder activism expenses of $4 million from the same period in 2015. The increase was principally driven by a favorable 2015 adjustment related to the DPIM extended coverage program, an unfavorable 2016 adjustment related to the DPIM extended coverage program, and unfavorable product warranty adjustments. Engineering, research, and development expenses were flat with the same period in 2015. Interest expense net decreased $3 million from the same period in 2015, principally driven by debt repayments and refinancing, partially offset by unfavorable mark-to-market adjustments for our interest rate derivatives.
Cash interest expense increased $3 million from the same period in 2015, principally driven by the second quarter 2015 refinancing of our 7 1/8 senior notes that paid interest in May and November, with additional Term Loan B3 borrowing that pays interest monthly. Income tax expense for the first quarter of 2016 was $28 million, resulting in an effective tax rate of 36.9% versus an effective tax rate of 36.8% for the same period in 2015. Diluted earnings per share for the quarter was $0.33, excluding stockholder activism expenses of $0.01 and mark-to-market adjustments for our interest rate derivatives of $0.04.
Adjusted EBITDA for the quarter was $162 million, or 35.1% of net sales, compared to $190 million, or 37.7% of net sales for the same period in 2015. The decrease is principally driven by decreased net sales and unfavorable product warranty adjustments, partially offset by favorable material costs and lower manufacturing expense. Please turn to slide eight of the presentation for the Q1 2016 cash flow performance summary. Net cash provided by operating activities increased $27 million from the same period in 2015, principally driven by decreased operating working capital, lower incentive compensation payouts, and decreased excess tax benefit from stock, partially offset by decreased net sales and increased cash interest expense.
Adjusted free cash flow increased $15 million from the same period in 2015, principally driven by increased net cash provided by operating activities, partially offset by increased capital expenditures and decreased excess tax benefit from stock-based compensation. Allison continued its prudent approach to capital structure and allocation during the first quarter by settling $33 million of share repurchases, paying a dividend of $0.15 per share, and repaying $6 million of debt. We ended the quarter with a net leverage of $3.03 million, $299 million of cash, $461 million of revolver availability, and $161 million of authorized share repurchases capacity. Now I'll turn the call back over to Larry.
Larry Dewey (Chairman and CEO)
Please turn to slide nine of the presentation for the full year 2016 guidance update. We anticipate no meaningful relief from the global off-highway end market challenges and are affirming our full year guidance ranges released to the market on February 8. Net sales decrease of 6.5%-9.5% year-over-year, an Adjusted EBITDA margin of 32.5%-34%, an Adjusted Free Cash Flow of $400 million-$450 million, capital expenditures of $65 million-$75 million, and cash income taxes of $10 million-$15 million. Although we are not providing specific second quarter 2016 guidance, Allison does expect second quarter net sales to be down year-over-year and up sequentially. This concludes our prepared remarks. Melissa, please open the call for questions.
Operator (participant)
Thank you. At this time, we'll be conducting a question-and-answer session. If you would like to ask a question, please press star one on your telephone keypad. A confirmation tone will indicate your line is in the question queue. You may press star two if you would like to remove your question from the queue. For participants using speaker equipment, it may be necessary to pick up your handset before pressing the star keys. As a reminder, to allow for as many questions as possible, we ask that you limit yourselves to one question. Our first question comes from the line of Ross Gilardi with Bank of America Merrill Lynch. Please proceed with your question.
Ross Gilardi (Managing Director)
Yeah, good morning. Thank you.
Larry Dewey (Chairman and CEO)
Morning.
Ross Gilardi (Managing Director)
Larry, can you just talk a little bit more about the recent board changes and what they mean for the company? I mean, you've got some more outsiders on the board right now. Is there a push for management to pursue any new strategies, a different capital allocation approach that would be a notable change from what the company's already doing?
Larry Dewey (Chairman and CEO)
You know, in March, in fact, on the fourteenth, we announced the additional changes that you're referring to. And really, those continue our efforts that we've made over the past couple of years to refresh, transform, and strengthen the composition of the board as the sponsors have sold down their investment. And as you noted, we added some significant industrial operational expertise and Asian business acumen by expanding the board. We added two seats, and we appointed Stan Askren and Richard Lavin as directors. And then, of course, on this year's ballot, we've also provided our shareholders the opportunity to vote on a candidate who provides additional shareholder representation by nominating Jamie Starr of Longview Asset Management to fill the vacancy created by Greg Ledford's retirement.
Then we also announced some changes to adopt best-in-class corporate governance practices. We amended our bylaws to immediately implement a majority voting standard in an uncontested director election. Also provide proxy access to qualified shareholders at the 2017 annual meeting, and then we submitted a charter amendment to our stockholders, that, if approved, will implement the annual election of our directors starting at our annual meeting next year. So we'll end up with a board made up of 11 directors, 10 of whom are independent, and six of that 10 who have joined the board in the past years, including Greg Spivy of ValueAct, and of course, as I previously mentioned, assuming he's elected, Jamie Star of Longview Asset Management. So it's really part of the transition of the board.
We continue, as you might imagine, to have dialogue over capital allocation. I would say at this point in time, if we had made changes, we would announce those. But we continue the march and continue to look and see what is the most prudent course of action relative to capital allocation. Again, from an operating standpoint, as we've said on a number of occasions, our task is to drive the results and then put that in front of the board, and then the board can decide on behalf of all stockholders what's the best use of the capital that we are generating.
Ross Gilardi (Managing Director)
Thanks very much.
Larry Dewey (Chairman and CEO)
Yeah.
Operator (participant)
Thank you. Our next question comes from the line of Jerry Revich with Goldman Sachs. Please proceed with your question.
Jerry Revich (Managing Director)
Good morning, everyone.
Larry Dewey (Chairman and CEO)
Morning.
Dave Graziosi (President and CFO)
Morning.
Jerry Revich (Managing Director)
Dave, can you talk about the EBITDA bridge in the quarter? What was the headwind from the warranty charge that you took in the first quarter of this year? And, what's the outlook for warranties from here? And, can you talk about if pricing was a benefit to margins on a year-over-year basis? Thanks.
Dave Graziosi (President and CFO)
Sure. The warranty adjustments, again, talking EBITDA rates, so it excludes the DPIM charges and credits that we mentioned here on the call. As is, as you know, in prior quarters in our results, we typically look at our warranty accruals on a quarterly basis. That's based on extensive product experience use in the field, et cetera. So I would not describe anything in the quarter as unusual. Our normal cadence is to make adjustments, whether those are up or down. Unfortunately, in the first quarter, there were a number of situations where, as we updated our experience, we recorded some additional provisions. I would say overall for the year, our expectations have not changed significantly relative to warranty.
On the price side, as we talked about on the fourth quarter call, for full year, we're in the range of $5 million-$10 million for total price year-over-year. First quarter, frankly, being the leanest of the four quarters relative to price, just given the activity level that we had in the first quarter of last year, as you'll recall, significant, you know, price appreciation last year, and some of that was run-rated, frankly, from 2014. So, again, you know, we're not changing the guide relative to price for full year or warranty for that matter.
Larry Dewey (Chairman and CEO)
Hey, Jerry, one thing I'll add, this is Larry. You know, when we look at situations, we feel very good about the quality improvements we have made. We did have for the adjustments that we made, we did have a couple of situations, spills, as we call them, that we had identified actually last year. And as we continue to look at it, we take a very aggressive approach to going after those on behalf of the customer. And so as we looked at where we were at, we said, "Look, we think that we're gonna need a little more in those funds to go after that and maintain the Allison brand promise in the field." And that's really where it comes from.
It's not a fundamental change in the run rate. It's really directed towards very specific field action activities, and we think we've got our arms around that, but we are going after it very aggressively.
Jerry Revich (Managing Director)
Okay. Thank you.
Operator (participant)
Thank you. Our next question comes from the line of Rob Wertheimer with Barclays. Please proceed with your question.
Rob Wertheimer (Senior Industrials Analyst)
Yeah, good morning, everybody. My question is on if you have a view on U.S. inventories and straight truck. Inventories have come off a bit, which is nice, still at pretty elevated levels. I'm not sure if we know what the right level is in a low interest rate environment, how far down you think inventories might come, and whether that'll be flushed out this year?
Dave Graziosi (President and CFO)
Well, you know, you're probably looking at the same charts I'm looking at right now relative to the Class 6, 7 truck inventory, the retail sales ratio, and the Class 8 straight truck inventory. Those are a couple that we pay close attention to because they're a big part. You know, we have seen, you could argue, the Class 8 has moved around a fair amount, but it's within the range, but it's at the higher range, high range, you know, Class 6, 7 looks to be in a little better shape from the normal. You know, I think the low interest rates does make that situation a little less painful to folks, and so you probably alter the fundamental equation of cost of inventory versus the lost sales perspective, and so people are probably carrying a little more. We would expect
You know, and we talked about this. We talked that we thought early in the year that folks would be taking some actions to bring that down a little closer to the target point, the center point of the range. We haven't. We've seen a few corrections in recent months, but we're not where we need to be now. You know, it's end of April, so I guess we've got a couple of months in the quarter, in the half. But I would say that we would expect it probably will take a little longer than the first half for folks to bring that in line.
Rob Wertheimer (Senior Industrials Analyst)
Thanks.
Dave Graziosi (President and CFO)
Yep. Yeah.
Operator (participant)
Thank you. Our next question comes from the line of Jamie Cook with Credit Suisse. Please proceed with your question.
Jamie Cook (Managing Director)
Hi, good morning. I guess a couple questions. One, you know, the parts was down again meaningfully this quarter. Can you just talk about what you're seeing in the different divisions or the different segments, and whether you're seeing any signs of bottoming, maybe in sort of the off-highway markets? And I know the rest of world on-highway markets were pretty good. And then, Dave, I guess my other question is, as I—as you sit here and you think about, you know, where we are in 2016, and maybe it's too premature to talk about 2017, but based on your view of the business today, do you think there are incremental, you know, cost-cutting opportunities that Allison can undergo?
or do you feel like most of these markets are pretty bottomed out, that we won't have to think about that as we approach 2017? Thanks.
Dave Graziosi (President and CFO)
Sure. The terms of parts, as we talked about here for first quarter, really consistent with our thoughts around that. On-highway a bit better, off-highway continuing to be challenged is probably a nice way of putting that. You know, the reality is, we think about you know, just looking at the pieces for North America off-highway service, you know, we expect reasonably flat results, you know, Q2 through four with Q1 levels. So, as we look outside of North America, again, pretty flat across the quarters. So, overall, as I said, a bit softer than I believe we expected for full year at some level. We continue to spend a fair bit of time addressing inventories in the channel and trying to figure out where those sit.
As you know, we had talked about on the fourth quarter call, there was the issue raised about hearing some things from the channel, maybe, a bit better than people were expecting. The reality, as we said at the time, that was not really consistent with what we're seeing, and I think, bluntly stated, as we look at the balance of the year, it continues to be extremely challenged. So, overall, expectations are down significantly, year-over-year, as we talked about on the fourth quarter call. You know, and again, we'll keep an eye on things, but it becomes very much a post-2016 world to focus on at this point in terms of aftermarket. So, we'll get to that.
To your, you know, question in terms of 2016 versus 2017, you know, we continue to keep a close eye on cost. As we talked about on the fourth quarter call, there's some cadence of that as we so-called earn our way into the year and see how business conditions are presenting themselves and opportunities for that matter to Allison. So, as we said earlier, you know, our thought process is we're gonna get after the opportunities that are meaningful and that are a good investment. But, you know, again, we're taking a very cautious view as the year rolls out here from a cost perspective. And, you know, there's a number of things that we can do with levers in the business from a cost perspective. We've done some of that already.
There are other opportunities there, but, you know, frankly, some of that is gonna be tied to the volume, cadence that we see. We continue to constrain output through manning, and that's, you know, largely a variable process for us to look at on a very consistent basis. Beyond that, you know, we will scale spending to whatever the business conditions are, you know, presented to the business. But overall, we are not gonna move away from our focus on strategic initiatives and more importantly, some of the growth initiatives we've launched here more recently.
Jamie Cook (Managing Director)
Okay, thanks. We'll get back in queue.
Operator (participant)
Thank you. Our next question comes from the line of Larry De Maria with William Blair. Please proceed with your question.
Larry De Maria (Group Head of Global Industrial Infrastructure)
Hi, thanks. Good morning, everybody.
Dave Graziosi (President and CFO)
Good morning.
Larry De Maria (Group Head of Global Industrial Infrastructure)
Just a question on the EBITDA margin cadence throughout the year. Obviously, margin were down year-over-year, but still pretty solid. And you noted sales will increase sequentially in the second quarter. So when should we start to see these lower margins throughout the year to get you down towards the guidance level? Can you just give us a help-- some help on the cadence of margins throughout the year?
Dave Graziosi (President and CFO)
Sure. You know, as we typically see with the business, there is some seasonality. You know, our sales in the first half are usually higher than the second half. There are a number of reasons for that. We don't see this year playing out any differently from that perspective in terms of run rating. You know, as we talked about with the Q2 expectations on sales, we would look at that as probably one of the higher, the highest quarter for the year at this stage. Certainly second half tailing off a bit. You know, as I said, there's seasonality in there. If you look at the margins, they typically are gonna follow, for the most part, volumes.
So when you look at first half, second half, we do have EBITDA margins higher in the first half than the second half. And historically, I think, as you know, our Q4 results typically are some of the lower EBITDA margins because of the amount of down days, holidays, et cetera, that are baked into the fourth quarter. So, again, we don't expect that to, you know, be a different outcome for this year.
Larry De Maria (Group Head of Global Industrial Infrastructure)
And if that was to change dramatically, would it just simply be a result of volumes doing better, or do we think it could be outside pressure on aftermarket, if markets stabilize and did a little bit better this year?
Dave Graziosi (President and CFO)
The key story with aftermarket this year is really off-highway. You know, as I said earlier, I'd like to tell you that there's a better opportunity there near term, but we try to be as transparent as possible, and I will tell you there is nothing that we're aware of that would, you know, lead you to that conclusion at this point for 2016. So, you know, we continue to have very low expectations for off-highway aftermarket this year.
Larry De Maria (Group Head of Global Industrial Infrastructure)
Got it. Thank you.
Operator (participant)
Thank you. Our next question comes from the line of Ann Duignan with JPMorgan. Please proceed with your question.
Ann Duignan (Managing Director)
Hi, good morning, everyone.
Larry Dewey (Chairman and CEO)
Good morning.
Ann Duignan (Managing Director)
Can you update us on the launch of the TC10? I think I noticed yesterday that PACCAR is now offering the product in their lineup.
Larry Dewey (Chairman and CEO)
Yeah, you know, as you know, we've been released in Navistar vehicles with the N13 engine. In the last several months, they've announced, and in fact, are taking orders with the Cummins ISX15 as well. That's at Navistar. And then, as you correctly noted here, I think it was last Thursday, PACCAR announced the engineering program leading to a release in the Kenworth T680 and T880, as well as the Peterbilt 567 and 579, with both PACCAR and Cummins engines. And so, you know, that engineering program has begun. We are very actively engaged with them.
You know, there'll be validation and some work that needs to occur here, and you know, they accordingly haven't announced the exact timing of the production release, but the fact is, we're en route towards that end.
Ann Duignan (Managing Director)
Okay, appreciate that. Just a quick follow-up on the severe service segment. Are you seeing any pickup in demand on the back of the highway bill, or too early to tell, or can you make the connection?
Larry Dewey (Chairman and CEO)
You know, we you know, the overall Class A straight truck, you know, everyone's trying to get a handle on how far down that's gonna be year-over-year in terms of the total market size. So we haven't seen yet any appreciable difference there. We did have within our planning some increase in share as we continue to drive programs like the PayDirt program, which is targeted towards construction. We have seen good results from that this year. So one of the things we've got to do as part of our backcast process is, as we look at the share numbers, and that's really what we're after when we do that, of course, the denominator is what was the industry volume.
So we might gain some insights at that point in time as to any impact, but we don't have that as we sit here today.
Ann Duignan (Managing Director)
Okay, I appreciate that. Thank you.
Larry Dewey (Chairman and CEO)
Yep.
Operator (participant)
Thank you. Our next question comes from the line of Tim Thein with Citigroup. Please proceed with your question.
Tim Thein (Analyst)
Thanks. And Dave, just to come back one more time on the aftermarket, just in light of your caution on off-highway, do you still feel that the down 6% for the full year is still an appropriate number to be thinking about?
Dave Graziosi (President and CFO)
Yeah, I would say, you know, Matt, there's, there's some slight offset to, you know, what we've seen more recently in terms of the off-highway business, but overall, it's, it's in that range.
Tim Thein (Analyst)
Okay, got it. Larry, maybe just talk a little bit about if you've seen any releases in the international markets, that at least that number can bounce around a bit. Let's say, maybe you're starting to get some traction in addition to a little bit more, a little better tone in terms of what some of the European truck and bus makers are saying. Maybe just a word on the international on-highway markets, please.
Larry Dewey (Chairman and CEO)
Sure. In terms of the releases, as you know, we've probably over-focused on some of that. I mean, it's necessary, but the release is not enough. And you know, we've in the past have gotten a number of releases, and what we've really stepped back on is there needs to be certainly a focus on releases, but really driving those releases through the OEM into the end market. And you know, I would say as far as releases, we've certainly seen some of the positioning in China refuse, some of the positioning in India truck. Europe, it's a big change is the MAN. When I was over there, gosh, a lot of years ago, more than I care to count, we were chasing MAN, and the guys have finally broken through there.
So that's a big one, both in Europe as well as, Latin America. In terms of releases, I would say probably the volume drivers are more the focus on, the end users. You know, Europe, there's some pickup in delivery activity, some construction activity, continued efforts there. China, small volumes, but starting in the refuse space, starting to see some of that same thing in Latin America. So there's probably one of the big ones is Japan, where we have had some breakthroughs in the rental market there. Rental vehicles cracked a couple of big accounts, and that's generating into some market momentum, which is driving some of their numbers.
So, it's while we continue to focus, of course, on releases, it really is step one of a three-step process, secure the release, promote the release through the OEM, and then sell the end user. And we're, as part of our growth initiatives, really putting a lot of attention to the second and third steps in that process.
Tim Thein (Analyst)
All right, thanks a lot. I appreciate it.
Operator (participant)
Thank you. Our next question comes from the line of Neil Frohnapple with Longbow Research. Please proceed with your question.
Neil Frohnapple (VP and Senior Research Analyst)
Hi, good morning, and congrats on a great quarter, guys.
Larry Dewey (Chairman and CEO)
Good morning.
Neil Frohnapple (VP and Senior Research Analyst)
I think you previously expected engineering expenses for 2016 to be down in the $5 million range year-over-year. Does the TC10 release at PACCAR change this outlook at all? And I guess just a brief follow-up, you know, would you guys still expect SG&A to be flattish with 2015, including a few of the one-timers that occurred in the first quarter?
Larry Dewey (Chairman and CEO)
Hi, Neil, this is Fred. On the engineering, the expectation is still flattish throughout 2016, with really no meaningful, you know, adjustment needed with the TC10 activities at PACCAR. From an SG&A standpoint, we would still expect, you know, consistent with what we talked about on the Q4 call. Really, if you look at SG&A, I think if you exclude the stockholder activism expense from the first quarter, it's gonna be pretty level at that point, as you model out Q2 through Q4.
Neil Frohnapple (VP and Senior Research Analyst)
All right, thanks for the help.
Operator (participant)
Thank you. Our next question comes from the line of Joe O'Dea with Vertical Research Partners. Please proceed with your question.
Joe O'Dea (Partner)
Hi, good morning. It sounds like relative to the initial outlook that maybe the service side, a little bit later, but offset with some of the North America on highway. Maybe just, you know, whether you can kind of confirm that. And then within the North America on highway, it seemed like bus was particularly strong on the build front. And is that related to state budgets and spend picking up there? Or was there something timing related that was beneficial in the quarter?
Larry Dewey (Chairman and CEO)
You know, you know, as we look at the quarter, I think you hit it right on the head. You know, we've seen a little bit of headwind in the parts driven by the off-highway. Certainly, off-highway continues to be challenged. You know, the two positives, North America on-highway is a large piece of the overall end market mix. And then, of course, the performance in outside North America on-highway. So those were kind of the pluses there. You know, as we look forward and to comment on the bus, certainly we have seen, and we're speaking of school bus here, we have seen some higher numbers there.
What we're looking at very closely is the issue of timing versus an absolute level. We are not seeing the data, which would suggest the overall demand is gonna be higher. So then, you know, we are viewing it as, at this time, as a timing issue. Now, obviously, we'll watch the out months and see how that schedule goes. But all of the OEMs in that space are taking higher levels of schedules than what you would see normally on a seasonality basis, vis-a-vis, an overall total forecast for the year. So right now, we're looking at it as largely timing. You know, we'll certainly apprise folks if we think it results in a meaningful change to the overall volume for the year as we watch the out-month schedules roll in.
Joe O'Dea (Partner)
Okay, thanks very much.
Operator (participant)
Thank you. Our next question comes from the line of Alex Potter with Piper Jaffray. Please proceed with your question.
Alex Potter (Senior Research Analyst)
Hi, guys. Thanks. Was wondering if you could comment a bit, I guess, on some competing technologies, dual clutches, AMTs, and then also, I recently started getting a little bit more noise from a couple OEMs regarding fully electric buses. So I'd be interested in getting your commentary on whether you think any of those technologies have a leg to stand on, whether there's any updated thoughts on any of that plan.
Larry Dewey (Chairman and CEO)
Well, let's kind of take them in turn there. Relative to AMTs, they certainly represent an improvement over a manual transmission, although in medium duty, they kind of penetrated to, you know, say, call it low double digits, and then they've kind of receded back into low single digits, and that's been part of our share increase over the last couple of years, where we've come out of the high sixties back through the what had been the previous high of low seventies into I think we estimate about 76% in 2015. So we've been able to demonstrate the relative value there in the Class 6, 7 truck.
Obviously, the battleground now is in the Class 8 tractor market, where we're coming in, actually with our 3000 Highway Series, with some of the baby 8s, as we call them, smaller engines. That's been a nice little pickup for us. And then, of course, the TC10 coming into that space. And one of the things that we continue to focus on is what is the value proposition relative to the fuel efficiency of the TC10. The customers have been very pleased with that. We've had a number of fleets, the number of fleets continues to increase.
As of early this month, we've had almost 100 discrete customers, 209 fleets, where some of those customers have multiple fleets, and about 15% of them have already reordered. So we're seeing a nice acceptance there, and we'll continue to drive that process. So that's the AMT. As far as the DCT... You know, the probably the thing that I could say that would be fair to acknowledge for them is the launch capability is a lot better than the AMT. So that's a plus.
Having said that, the DCT does rely on a clutch to start the vehicle, and so they limit the clutch engagement torque at start and launch to avoid burning the clutch, and that results in a lower launch capability, which then over a start-stop cycle, which is where it's targeted, ends up with a differential in productivity that we think plays well for us. We'll be coming forward with updated and validated testing relative to fuel economy, and we're pretty confident what that's gonna show. So we'll be going to the market with that.
We have given the, given the long-standing total cost of ownership and our knowledge of the duty cycles and the durability of the Allison, we've come out with a seven-year coverage in the school bus space that we think will be very attractive. In fact, as we understand it, a number of school districts are writing that into their specs, and what we offer that for is frankly a fraction of what the DCT supplier is offering it for, so that just widens the value proposition we think that we have. As far as the electric vehicles, you know, certainly there's a lot of excitement over that, reminiscent of all the excitement for hybrids, perhaps.
Where you see it most significantly is in China, whereby government fiat, they are directing the purchase of what they call new energy vehicles, most of which are electric. That has negatively impacted some of the volumes that we've had there in transit bus. On the one hand, you know, if in that context, if the government says that the sun is gonna rise at midnight, you better be putting your suntan lotion on at 11:45 P.M. So clearly, there's a legislative or really not even legislative, a directive to purchase that. That is changing. Some of the subsidies have altered the economics of that proposition, where a new energy vehicle or an electric bus costs significantly less than a conventional, much less a hybrid.
So that was something which certainly encouraged the properties or supported the properties in meeting the direction from the central government. That's changing. Those subsidies are gonna go towards building infrastructure, and so the incentive for the actual vehicle purchase is gonna change. That probably, given the direction from the government, isn't going to significantly alter the near-term mix.
What we are seeing, however, as we somewhat expected, frankly, is that the vehicles themselves, if you understand the limitations of battery technology, at least as it exists today, the vehicles themselves are not living up to, in a number of cases, the standards of performance that the customers had been used to in a conventional vehicle, whether it's the ability to handle the route or whether it's the uptime as a result of some of the challenges of a fully electric vehicle. So there's a number of issues that are yet to play out, but clearly there's a lot of interest. You know, we have. In fact, I'll be getting an update later this week on what we might do to position a variant of our product into that space.
The challenge becomes a lot of these are like science fair projects, and you can dump a ton of money into what is a very, very small volume of vehicles. So we wanna do it smart. We wanna be there, you know, so that if some of the technical advancements are there, particularly relative to battery technology, that we're positioned for it. But we also wanna do it in a responsible manner. Those are. That's kind of how we're thinking about some of the electric vehicles.
Alex Potter (Senior Research Analyst)
Thank you very much. I appreciate all the color.
Larry Dewey (Chairman and CEO)
Yeah.
Operator (participant)
Thank you. Mr. Dewey, there are no further questions at this time. I'd like to turn the floor back to you for any final remarks.
Larry Dewey (Chairman and CEO)
Well, certainly we appreciate everyone's time this morning and the support and interest that you've shown in Allison, and we'll look forward to updating you with the second quarter call here in about three months. So have a great day.
Operator (participant)
Thank you. This concludes today's teleconference. You may disconnect your lines at this time. Thank you for your participation.
